User manual AYP SP185H42STA RP - PARTS-LIST

TRACTOR - - MODEL NUMBER SP185H42STA SCHEMATIC RED BLACK BATTERY A AMMETER (OPTIONAL) RED RED M STARTER BLACK FUSE WHITE SOLENOID RED B G L BLACK S M A1 A2 CLUTCH / BRAKE (PEDAL UP) WHITE IGNITION SWITCH SEAT SWITCH (NOT OCCUPIED) WHITE BLACK BLACK BLACK BLACK HOUR METER (OPTIONAL) BLACK ATT'MENT CLUTCH (CLUTCH OFF) GROUNDING CONNECTOR SPARK PLUG GAP (2 PLUGS ON TWIN CYL. ENGINES) 28 VOLTS AC MIN. @ 3600 RPM (CHARGING SYSTEM DISCONNECTED) BLACK BLUE FUEL LINE IGNITION UNIT CHARGING SYSTEM OUTPUT 3 AMP DC @ 3600 RPM RED LIGHTING SYSTEM OUTPUT 5 AMP AC @ 3600 RPM FUEL SHUT-OFF SOLENOID (IF SO EQUIPPED) ORANGE DIODE ALTERNATOR 14 VOLTS AC MIN. @ 3600 RPM (LIGHTS OFF) NOTE YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WILL CHANGE WITH ENGINE SPEED. AT IDLE THE LIGHTS WILL DIM. AS THE ENGINE IS SPEEDED UP, THE LIGHTS WILL BECOME THEIR BRIGHTEST. IGNITION SWITCH POSITION CIRCUIT "MAKE" NONE A2+L NONE NONE BROWN BLACK HEADLIGHTS NON-REMOVABLE CONNECTIONS REMOVABLE CONNECTIONS WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. OFF M+G+A1 RUN/LIGHT B+A1 RUN START B+A1 B + S + A1 31 REPAIR PARTS TRACTOR - - MODEL NUMBER SP185H42STA ELECTRICAL 22 21 24 42 41 43 27 27 26 40 27 27 25 16 16 33 30 D. C. AM PE RE 52 S 8 45 28 27 55 29 2 1 90 32 TRACTOR - - MODEL NUMBER SP185H42STA ELECTRICAL KEY PART NO. NO. 1 2 8 16 21 22 24 25 26 27 28 29 30 33 40 41 42 43 45 52 90 163465 74760412 176689 176138 183759 4152J 4799J 146147 175158 73510400 4207J 121305X 175566 140401 179720 71110408 131563 178861 121433X 141940 180449 DESCRIPTION Battery Bolt Hex Hd 1/4-20 unc x 3/4 Box Battery Switch Interlock Harness Socket Light Bulb, Light # 1156 Cable Battery Cable Battery 6 Ga. Red w/16 wire 44" Fuse Nut Keps Hex 1/4-20 unc Cable Ground 12" Blk 6 Ga. Switch Plunger Nc Gray Switch Ign Key Ign Molded Generic Harness Ign Bolt Fin Hex 1/4-20 unc x 1/2 Cover Terminal Red Solenoid Ammeter Rectangular Protection Loop Cover Terminal NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 33 TRACTOR - - MODEL NUMBER SP185H42STA CHASSIS AND ENCLOSURES 29 212 17 159 30 24 28 39 18 24 166 26 25 26 209 5 5 209 9 25 31 209 208 208 11 207 26 64 209 35 10 1 13 209 33 142 37 209 145 37 2 142 14 209 35 14 34 208 206 209 38 26 chassis_elite value_stlt_3 34 TRACTOR - - MODEL NUMBER SP185H42STA CHASSIS AND ENCLOSURES KEY PART NO. NO. 1 2 5 9 10 11 13 14 17 18 24 26 28 29 30 31 33 34 35 37 38 39 58 64 142 145 159 166 206 208 209 212 -174619 176554 155272 168337X012 72140608 174996 179174X010 17490608 183394X505 126938X 74780616 73800600 183552 183549X599 169470X505 136619 179716X505 179717X505 72110606 17490508 175710 174714 150127 154798 175702 156524 169473X428 171875 170165 17670608 17000612 183550 5479J DESCRIPTION Chassis Drawbar Bumper Hood/Dash Dash P/L Bolt Carriage 3/8-16 x 1 Panel Dash Lh Panel Dash Rh Screw Thdrol 3/8-16 x 1/2 Hood Bumper Hood Bolt Fin Hex 3/8-16 unc x 1 Gr. 5 Nut Lock Hex W/Ins 3/8-16 unc Grille/Lens Asm(Includes #'s 29 and 212) Lens Grille Fender Bracket Fender Footrest LH Footrest RH Bolt RDHD SHT SQNK 3/8-16 x 3/4 Screw Thdrol 6/16-18 x 1/2 TYT Bracket Asm Pivot Mower Rear Bracket Pivot Duct Air Dash Lower STLT Plate Reinforcement STLT Rod Pivot Chassis/Hood Cupholder Screw Hwhd Hi-Lo #13-16 x 3/4 Bolt Shoulder 5/16-18 Screw Thdrol 3/8-16 x 1/2 Screw Hexwsh Thdr 3/8-16 x 3/4 Insert Grille Reflective Plug BTN BlK NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 35 TRACTOR - - MODEL NUMBER SP185H42STA GROUND DRIVE 57 120 89 63 212 69 197 161 169 198 83 14 163 82 165 156 8 168 159 158 162 70 59 61 41 66 65 56 64 50 116 202 150 48 81 21 10 112 166 38 35 39 27 49 47 120 34 37 36 35 151 51 32 30 62 52 36 52 32 16 95 30 28 26 16 26 29 22 19 24 200 263 77 71 78 74 75 76 73 16 263 199 16 84 27 55 53 77 15 26 25 96 26 1 drive-hydro.stlt_34 36 TRACTOR - - MODEL NUMBER SP185H42STA GROUND DRIVE KEY PART NO. NO. 1 8 10 14 15 16 19 21 22 24 25 26 27 28 29 30 32 34 35 36 37 38 39 41 47 48 49 50 51 52 53 55 56 57 59 61 62 63 64 65 -----165619 76020416 10040400 74490544 73800500 73800600 106932X 169498 73350600 106888X 19131316 76020412 175765 71673 169592 74760512 175578 120183X 19211616 1572H 179114 72110622 175556 127783 154407 123205X 72110612 73680600 73680500 105710X 105709X 17060620 140294 169691 17120614 8883R 175410 173937 10040700 DESCRIPTION Transaxle Hydro Gear 314-0510 (Order Parts From Transaxle Manufacturer) Rod Shift Pin Cotter 1/8 x 1 CAD Washer Lock Hvy Helical Bolt, Hex FLGHD 5/16-18 Gr. 5 Nut Lock Hex W/Ins 5/16-18 unc Nut Lock Hex W/Wsh 3/8-16 unc Knob Rod, Brake Hydro Nut Spring, Brake Rod Washer Pin Cotter 1/8 x 3/4 CAD. Rod, Parking Brake Cap, Parking Brake Bracket, Transaxle Bolt Hex Hd 5/16-18 unc x 3/4 Shaft, Foot Pedal Bearing, Nylon Washer Pin, Roll Pulley, Composite Bolt Rdhd 3/8-16 unc x 2-3/4 Gr. 5 Keeper, Belt Idler Pulley, Idler, V-Groove Bellcrank Clutch Grnd Drv STL Retainer, Belt Bolt Carr Sh 3/8-16 x 1-1/2 Gr. 5 Nut Crownlock 3/8-16 unc Nut Crownlock 5/16-18 unc Link, Clutch Spring, Return, Clutch Screw 3/8-16 x 1-1/4 V-Belt, Ground Drive Keeper, Center Span Screw 3/8-16 x .875 Cover, Pedal Pulley, Engine Bolt Hex 7/16-20 x 4 x Gr. 5-1.5 Washer KEY PART NO. NO. 66 69 70 71 73 74 75 76 77 78 81 82 83 84 89 95 96 112 116 120 150 151 156 158 159 161 162 163 165 166 168 169 197 198 199 200 202 212 154778 142432 134683 169183 169182 137057 121749X 12000001 123583X 121748X 165596 123782X 19171216 169594 169373X428 170201 4497H 19091210 72140608 73900600 175456 19133210 166002 165589 183900 72140406 73680400 74780416 165623 17490510 165492 165580 169613 169593 169612 72140508 72110614 145212 DESCRIPTION Keeper Belt Engine Screw Hex Wsh Hi-Lo 1/4-1/2 unc Guide Belt Strap Torque Lh Hydro Strap Torque Rh Hydro Spacer, Axle Washer 25/32 x 1-1/4 x 16 Ga. E-Ring Key, Square Washer 25/32 x 1-5/8 x 16 Ga. Shaft Asm. Cross Hydro Spring Torsion T/A Washer 17/32 x 3/4 x 16 Ga. Link Transaxle Console, Shift Control Asm Bypass Hydro Retainer Spring 1" Zinc/Cad Washer 9/32 x 3/4 x 10 Ga. Bolt RDHD SQNK 3/8-16 unc x 1 Nut Lock Flg 3/8-16 unc Spacer Retainer Washer 13/32 x 2 x 10 Ga. Washer Srrted 5/16 ID x 1.125 Bracket Shift Mount Hub Shift Bolt Rdhd Sqnk 1/4-20 x 3/4 Gr. 5 Nut Crownlock 1/4-20 unc Bolt Hex Fin 1/4-20 unc x 1 Gr. 5 Bracket Pivot Lever Screw 5/16-18 x 5/8 Bolt Shoulder 5/16-18 x .561 Plate Fastening Lt Nyliner Snap-In 5/8" ID Washer Nyl 7/8 ID x .105 Bolt Shoulder 5/16-18 unc Bolt Rdhd Sqnk 5/16-18 unc x 1 Bolt Carr Sh 3/8-16 x 1-3/4 Gr. 5 Nut Hex flange Lock NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 37 TRACTOR - - MODEL NUMBER SP185H42STA STEERING ASSEMBLY 38 12 39 1 41 42 37 37 36 44 51 54 91 43 88 71 68 46 8 6 17 2 87 5 65 46 8 67 67 29 67 13 6 87 3 68 11 26 32 5 4 43 29 82 40 43 15 15 15 29 10 28 30 95 8 steering_pl.lt_47 38 TRACTOR - - MODEL NUMBER SP185H42STA STEERING ASSEMBLY KEY PART NO. NO. 1 2 3 4 5 6 8 10 11 12 13 15 17 26 28 29 30 32 36 37 38 39 40 41 42 43 44 46 51 54 65 67 71 68 82 87 88 91 95 184704X428 184706 169840 169839 6266H 121748X 12000029 175121 10040600 73940800 136518 145212 180641 126847X 19131416 17000612 76020412 130465 155099 152927 159946X428 19182411 73540600 159945 145054X428 121749X 180640 121232X 73540400 71130420 160367 72110618 175146 169827 169835 173966 175118 175553 188967 DESCRIPTION Wheel Steering Axle Asm Cast Iron LT Spindle Asm LH Spindle Asm RH Bearing Race Thrust Harden Washer 25/32 x 1-5/8 x 16 Ga. Ring Klip #t5304-75 Link Drag Washer Lock Hvy Hlcl Spr 3/8 Nut Hex Jam Toplock 1/2-20 unf Spacer Brg Axle Front Nut Hex Flange Lock Shaft Asm Steering Bushing Link Drag Washer 13/32 x 7/8 x 16 Ga. Screw 3/8-16 x .75 Pin Cotter 1/8 x 3/4 Rod Tie Bushing Strg Screw Insert Cap Strg Wh Washer 9/16 x 1 1/20 x 11 Ga. Crownlock nut Adaptor Wheel Strg Boot Steering Dash Washer 25/32 x 1 1/4 x 16 Ga. Extension Steering Shaft Cap Spindle Fr Top Blk Nut Crownlock 1/4-28 Bolt Hex 1/4-28 unf x 1-1/4 Gr. 8 Spacer Brace Axle Bolt RDHD SQNK 3/8-16 x 2 1/4 Steering Asm Axle, Brace Bracket Susp Chassis Front Washer Flat .781 x 1-1/2 x .14 Bolt Shoulder 7/16-20 unc Clip Steering Washer Harden .739 x 1.637 x 060 NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 39 TRACTOR - - MODEL NUMBER SP185H42STA ENGINE 2 3 72 1 81 13 4 78 38 32 44 46 14 78 33 31 33 45 29 23 37 OPTIONAL EQUIPMENT Spark Arrester engine-bs.1cyl_48 KEY PART NO. NO. 1 2 3 4 13 14 23 29 31 32 33 37 38 44 170551 17720408 ------137352 165291 148456 169837 137180 185534 140527 123487X 137040 181654 17670412 DESCRIPTION Control, Throttle Screw Hex Thd Cut 1/4-20 x 1/2 Engine Briggs Model 31P777 (Order Parts from Engine Mfg.) Muffler Muffler Gasket Tube Oil Drain Shield, Browning/Debris Guard Arrester, Spark Tank, Fuel Cap, Fuel Clamp, Hose Blk Line, Fuel Plug Drain Oil Easy Screw Hex Wsh THDROL 1/4-20 x 3/4 KEY PART NO. NO. 45 46 72 78 81 17000612 19091416 183906 17060620 73510400 DESCRIPTION Screw Hex Wsh Thdrol 3/8-16 x 3/4 Washer 9/32 x 7/8 x 16 Ga. Screw Socket Head 5/16-18 x 1 Screw 3/8-16 x 1-1/4 Nut Keps Hex 1/4-20 unc NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm For engine service and replacement parts, call the toll free number for your engine manufacturer listed below: Briggs & Stratton 1-800-233-3723 Kohler Co. 1-800-544-2444 Tecumseh Products 1-800-558-5402 Honda Engines 1-800-426-7701 Kawasaki 1-949-460-5688 40 TRACTOR - - MODEL NUMBER SP185H42STA SEAT ASSEMBLY 1 8 9 14 8 9 7 5 6 22 21 7 10 2 24 5 16 15 11 4 13 17 seat_lt.knob_9 12 3 KEY PART NO. NO. 1 2 3 4 5 6 7 8 9 10 11 12 188704 180166 71110616 19131610 145006 73800600 124181X 17000616 19131614 180186 166369 121246X DESCRIPTION Seat Bracket Pivot Fender Bolt Fin Hex 3/8-16 unc x 1 Washer 13/32 x 1 x 10 Ga. Clip Push-In Nut Hex w/Ins. 3/8-16 unc Spring Seat Cprsn 2 250 Blk Zi Screw 3/8-16 x 1.5 Smgml Washer 13/32 x 1 x 14 Ga. Pan Seat Knob Seat Bracket Mounting Switch KEY PART NO. NO. 13 14 15 16 17 21 22 24 121248X 72050412 134300 121250X 123976X 171852 73800500 19171912 DESCRIPTION Bushing Snap Blk Nyl 50 Id Bolt Rdhd Sqnk 1/4-20 x 1-1/2 Spacer Split 28x 88 Spring Cprsn Nut Lock 1/4 Lge Flg Gr. 5 Zinc Bolt Shoulder 5/16-18 unc Nut Hex Lock W/Ins 5/16-18 Washer 17/32 x 1-3/16 x 12 Ga. NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 41 TRACTOR - - MODEL NUMBER SP185H42STA DECALS 11 7 16 4 4 3 10 20 1 9 6 2 8 2 12 5 14 13 KEY PART NO. NO. 1 2 3 4 5 6 7 8 9 10 11 156811 190534 190428 189289 189288 170563 190746 179128 190429 157141 190430 DESCRIPTION Decal Oper Decal Chassis Decal Hood LH Decal Side Panel Logo Decal HP Engine Decal Warning, Keep Hand Away Decal Replacement Parts Decal Deck "B" 42" Decal Fender Logo Decal Fender Danger Decal Ins Strg Whl KEY PART NO. NO. 12 13 14 16 20 ------173587 173589 160396 190427 145005 166960 179768X428 179769X428 138311 190358 190359 DESCRIPTION Decal Fend Reflector Rh Decal Fend Reflector Lh Decal V-Belt Schematic Decal Hood Rh Decal Bat Dan/Psn Decal By Pass Lt Hydro Pad Footrest LH Pad Footrest RH Decal Handle Lft Height Adjust Manual Owner's (English) Manual Owner's (Spanish) WHEELS & TIRES 1 2 5,8 4,10 KEY PART NO. NO. 1 2 3 4 5 6 7 8 9 10 11 -59192 65139 106222X 59904 106732X624 278H 9040H 106108X624 122082X 7152J 104757X428 144334 DESCRIPTION Cap Valve Tire Stem Valve Tire F T 15 x 6 0 - 6 Service Tube Front (Service Item Only) Rim Asm 6" front Service Fitting Grease (Front Wheel Only) Bearing Flange (Front Wheel nly) Rim Asm 8" rear Service Tire R T 20 x 10-8 Service Tube Rear (Service Item Only) Cap Axle Blk 1 50 x 1 00 Sealant, Tire ( 10 oz. Tube) 7 3,9 6 11 wheel_1 NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 42 TRACTOR - - MODEL NUMBER SP185H42STA LIFT ASSEMBLY 7 8 5 13 4 11 12 13 19 13 20 6 3 2 6 5 1 4 15 31 32 20 17 18 16 20 19 31 32 13 20 15 lift-rh.1piece_3 KEY PART NO. NO. 1 2 3 4 5 6 7 8 11 12 13 159461 159476 178981 12000002 19211621 120183X 125631X 124526X 139865 139866 4939M DESCRIPTION Wire Asm Inner/Sprg W/plunger Shaft Asm Lift RH w/Inf Pin Groove 2" E Ring #5133-62 Washer 21/32 x 1 x 21 Ga. Bearing Nylon Blk 629 Id Grip Handle Button Plunger Link Lift LH Fixed Length Link Lift RH Fixed Length Retainer Spring KEY PART NO. NO. 15 16 17 18 19 20 31 32 173288 73350800 175689 73800800 139868 163552 169865 73540600 DESCRIPTION Link Front Nut Jam Hex 1/2-13 unc Trunnion Nut Lock W/Wsh 1/2-13 unc Arm Suspension Rear Retainer Spring Bearing Pvt Lift Nut Crownlock 3/8 - 24 NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 43 TRACTOR - - MODEL NUMBER SP185H42STA MOWER DECK 67 158 185 40 36 od _7 68 152 42 _c lu tc h_ m 40 143 144 159 40 145 44 56 53 52 55 146 48 142 54 33 32 147 21 5 140 21 21 21 139 21 134 136 136 5 31 30 184 59 45 150 46 148 106 105 104 103 101 102 103 105 104 106 102 134 135 116 117 119 113 1 118 2 142 138 2 147 34 2 21 118 119 117 116 2 21 23 24 25 26 113 16 3 4 149 15 20 14 18 29 28 27 5 6 13 19 21 18 11 10 9 42_deck_man-t-path_4. 8 44 TRACTOR - - MODEL NUMBER SP185H42STA MOWER DECK KEY PART NO. NO. 1 2 3 4 5 6 8 9 10 11 --13 14 15 16 18 19 20 21 23 24 25 26 27 28 29 30 31 32 33 34 36 40 44 45 46 48 52 53 54 182032X 72140506 138017 165460 4939M 178024 850857 10030600 140296 DESCRIPTION KEY PART NO. NO. 55 56 59 67 68 101 102 103 104 105 106 113 116 117 118 119 134 135 136 138 139 140 142 143 144 145 146 147 148 149 150 152 158 159 184 185 --155046 165723 141043 171598 144959 136420 71081010 19061216 10071000 160793 2029J 17060512 184219 133957 73930600 19121414 156941 159765X 155986 159763X 159767X 159768X 165890 157109 158634 165888 171977 131335 169022 165898 19091210 169676 17720408 72140614 19131410 188234 130794 186917 DESCRIPTION Arm, Idler Spacer, Retainer Guard TUV Idler Knob Round V-Belt, 42" Mower Mulcher Cover Screw, Pan Hd Phillip 10-24 x 5/8 Washer, Flat Washer, Lock Latch Assembly Nut, Weld Screw 5/16-18 x 3/4 Bolt, Shoulder Wheel, Gauge Nut Centerlock 3/8-16 Washer 3/8 x 7/8 x 14 Ga. Pin Head Rivet Bracket Asm. Whl Ga. R LH Bar Adjusting Gauge Wheel Bracket Asm Whl Ga. R RH Bracket Asm. Whl Ga. F RH Bracket Asm Whl Ga. F LH Arm Spring Brake Mower Bracket Arm Idler 42" Keeper Belt 42" Clutch Cable Pulley Idler Flat Bolt Carriage Idler Spring Extension Spring Return Idler Retainer Spring Yellow Washer 9/32 x 3/4 x 10 Ga. Clutch Cable 42" Screw Hex Thd Cut 1/4-20 x 1/2 Bolt Rdhd Sqn 3/8-16 unc x 1-3/4 Washer 13/32 x 7/8 x 10 Ga. Head Asm Cable Clutch Mandrel Assembly (Includes Housing Shaft and Shaft Hard ware Only - Pulley Not Included) Replacement Mower, Complete (Std. deck Order separately mulcher cover and gauge wheel components Key Nos. 101-106 and 5, 134, 136, 116-119) Mower Deck Assembly, 42" Bolt Bracket Asm Fr. Sway Bar 3/42 Bracket Asm Deck 42" Sway Bar Retainer Spring Bar Sway Deck Bolt 3/8-24 x 1.25 Gr. 8 patched Washer, Lock Washer, Hardened (The following Blades are avail able) 134149 Blade, Mulching 42" Std (for mulching mowers only) 139775 Blade Mulching 42" Premium (For better wear when mulching) 138971 Blade Mower 42" Hi-Lift (for bag ging and discharging) 137645 Shaft Assembly, Mandrel, Vented 128774 Housing, Mandrel, Vented 110485X Bearing, Ball, Mandrel 174493 Stripper, Mandrel Deck 72140505 Bolt, Carriage 5/16-18 x 5/8 132827 Bolt, Shoulder 159770 Baffle, Vortex 73680500 Nut 177563 Bracket, Deflector Mower 42" 105304X Cap, Sleeve 80 x 112 Blk Mower 123713X Spring, Torsion, Deflector 2 52 110452X Nut, Push Phos & Oil 130968X428 Shield, Deflector 42" Blk 19111016 Washer 11/32 x 5/8 x 16 Ga. 131491 Rod, Hinge 42" 6 75 W/G 173984 Screw Thdrol 187690 Washer, Spacer Mower Vented 173436 Pulley, Mandrel 178342 Nut, Toplock 72110612 Bolt Carr SH 3/8-16 x 1-1/2 Gr.5 131494 Pulley, Idler, Flat 73900600 Nut Lock 3/8-16 140088 Guard, Mandrel, LH 4497H Retainer 137729 Screw, Thdrol 1/4-20 x 5/8 T 133944 Washer, Hardened 139888 Bolt, Shoulder 5/16-18 unc 184907 Arm Assembly, Pad, Brake 178515 Washer, Hardened NOTE: All component dimensions given in U.S.inches 1 inch = 25.4 mm 45