8 7 CN25 DC B A 6 5 4 3 2 1 H MC 1000 ECU Crank + O2 Sensor signal O2 sensor com Crank Coolant Temp + 5 Vdc Supply CAN + Sys on LED Air Temp Sensor Fail LED Stepper A Stepper B Throttle Position Sensor Ground Stepper D Stepper C CAN Power Ground Fuel Pump Injector #2 Injector #1 +12V P1 A1 P1 A2 P1 A3 P1 B1 P1 B2 P1 B3 P1 B4 P1 C3 P1 D1 P1 D4 P1 E1 P1 E2 P1 E3 P1 E4 P1 F1 P1 F2 P1 F4 P1 G4 P1 H1 P1 H2 P1 H3 P1 H4 DIAGNOSTIC CONNECTOR 1 2 3 CN10 4 5 6 Green99 G K Line P2 A2 L Line P2 B2 Map Select P2 B3 Trim Down P2 C3 Chassis Ground P2 C4 Trim Defeat P2 D2 Trim Up P2 D3 Vign P2 E1 Temp LED P2 E2 O2 Heater P2 F1 Power Latch P2 F3 Cooling Fan P2 G1 Cooling Fan P2 G2 Power Ground P2 G3 Power Ground P2 G4 Ignition Coil P2 H1 P1 F2 P1 A1 P1 B3 P1 E3 P2 G2 P1 B1 P1 F4 P1 E4 P2 C4 P2 B2 P1 E1 P1 E2 P2 A2 P1 B2 P1 F1 P1 B4 P1 H4 P1 D1 P2 B3 P2 D2 P2 C3 P2 D3 P1 C3 P1 D4 P1 G4 P1 H1 P1 H3 P1 H2 P2 E2 P2 H1 P2 G3 P2 E1 P2 G4 P2 G1 P2 F3 P1 A2 P1 A3 P2 F1 Twisted Shielded Pair (TSP) Connect Shield to Black #4 GND two places White (TSP) White 70 Grey 62 Wh/Blu(TSP) Green 55 Black 10 Green 99 Black 4 Break-out at (TPS) CN3 same length Green Grey Twisted Shielded Pair (TSP) Connect Shield to Black #4 GND two places Break Out 3.5"at ECU White 98 Red Green Red Black 13 Yellow 2 Yellow 3 Yellow 1 Black 15 Black 14 Red 71 Blue SP9 Power Latch R2 EMS / Vbatt Power BA BA BA CN18 CN19 CN23 2 Blue Red 26 Orange P2 Grey Connector P1 Black Connector 55 Green White 98 Grey 63 +5 Vdc Splice Green 54 Green 53 Green 52 SP3 VCOIL Orange 30 Orange Orange Orange 32 31 33 H SP2 Sensor GND Grey Grey Grey Grey Grey Grey Grey Black Blue Blue Blue 64 1 11 81 82 Blue 83 Black 3 Brown 49 Black Black 13 Black 5 Black 2 54 64 White (TSP) Wh/Blu(TSP) Blue CN24 SWITCH PANEL 17 28 9 10 11 12 3 4 5 6 G 2 1 SP5 Battery GND SP4 Battery GND SP7 Vign,VBatt 21 1 75 SP6 VBATT CN5 1 2 Air Temp Sensor Black 2 4 Black Black 15 Black 8 Black 7 Black Brown 50 Orange 30 Brown 49 D1-1N5408 Brown 50 85 86 Brown 40 30 87 33 83 White 42 SP8 Pencil Coil Spark Plug 1 12 F Slide Connector Bullet Connector CN22 BA BA BA BA AB CN8 31 81 F Orange Black Red Ring Terminal ECU Chassis Ground D2 1N5408 D3 1N5408 L.Headlamp R. Headlamp 1 2 Blue CN6 Right Injector Injector 2 1 Battery Lug O2 Sensor Battery Cable Twisted Shielded Pair AB Tail Lamp 1 2 3 29 Yellow Yellow Yellow Black Green 1 Cooling Fan CN21 E Dead end and add HST to Wires for future Lambda sensor at deleted Cam Sensor Location 42 45 32 82 Orange Blue 40 29 CN7 2 1 Left Injector Injector E White Black Female connector (sockets) Male connector (pins) Insulated Splice Pushbutton Diode 28 Brown Black 1 2 Yellow BA ECU Chassis Ground CN12 CN13 Green Violet GREEN VIOLET YELLOW OFF RUN IGNITION SWITCH Black 50 RUN W/LTS Red 62 70 52 White Green Grey BA CD CN3 ABC TPS D Black Red CBA D HARNESS CONN. I.D. 22 9 Red 72 CB 1 12V, 8AH Batt Red 24 FUNCTION ECU ECU CRANK PICKUP THROTTLE POSITION SENSOR COOLANT TEMP. SENSOR AIR TEMP. SENSOR RIGHT INJECTOR LEFT INJECTOR IGNITION COIL DIAGNOSTIC DIAGNOSTIC COVER START BUTTON STOP BUTTON VOLTAGE REGULATOR STARTER SOLENOID FUEL PUMP VBATT + HEAD LAMPS HEAD LAMP TPA CLUTCH SWITCH IGNITION SWITCH COOLING FAN TAIL LAMP SWITCH PANEL SWITCH PANEL COVER STEPPER MOTOR RELAY BASE RELAY BASE TPA FUSE HOLDER FUSE HOLDER COVER CONNECTOR CINCH P/N 5800400001 32F CINCH P/N 5800400003 32F BLACK GREY AMP 963040-3 Jr. POWER TIMER PACKARD METRI-PACK CONN. 3F 12162182 AMP 963040-3 Jr. POWER TIMER AMP 963040-3 Jr. POWER TIMER AMP 963040-3 Jr. POWER TIMER AMP 963040-3 Jr. POWER TIMER FRAMATOME 211PC022S0021 DEUTSCH DTM SERIES DTM06-6S DEUTSCH DTM SERIES DTM04 0.156 INS. BULLET RECEPT. 1/4" RECESS 56139 QTY(2) 0.180 MALE BULLET CONN. 56128 OVER MOLD QTY(2) PACKARD WEATHER-PACK CONN. 4F 12015798 PACKARD METRI-PACK CONN. 2F 12162194 PACKARD WEATHER-PACK CONN. 2M 12010973 PACKARD WEATHER-PACK CONN. 2M 12010973 PACKARD METRI-PACK CONN. 2F 12020599 PACKARD METRI-PACK TPA 12034446 FEMALE TERMINAL SLIDE CONNECTOR MAGURA QTY(2) 0.156 INS. BULLET RECEPT. 1/4" RECESS 56139 QTY(3) PACKARD METRI-PACK CONN. 2F 15300027 PACKARD WEATHER-PACK CONN. 2M 12010973 DEUTSCH DTM SERIES DTM06-12S DEUTSCH DTM SERIES DTM04-12P PACKARD METRI-PACK CONN. 150.2 12162188 PACKARD METRI-PACK CONN. 5F 12033871 PACKARD METRI-PACK TPA 12033872 PACKARD 630 CONN. 2F 12085030 PACKARD COVER 12033731 BA CD CN17 Red 72 Red 24 Red 74 Red 21 P1 P1 CN-2 CN-3 CN-4 CN-5 CN-6 CN-7 CN-8 CN-10 BA Blue 48 Black/Yellow 45 Brown BA Red Green CN20 CD AB Black Red BA CB 3 CB 2 Start Button Stop Button Note: Stop Button is maintained opened or closed, Not Momentary Starter Solenoid C CN4 Clutch Black 7 Grey AB Red 73 F1 - 20A Red 75 11 29 CN16 53 63 Coolant Temp Sensor CN-10 CN-12 CN-13 CN-14 CN-15 CN-16 CN-17 CN-18,CN-19 CN14 1 2 2 1 M Fuel Pump AB C Black 50 Black 9 Black 5 Frame Ground M CN15 48 zwhite/Blu(SP) Twisted Shielded Pair BA White(TSP) Crank Pickup Black 8 Black/yellow Starter Motor CN2 1 2 2 1 B CN-18,19 CN-20 CN-21 CN-22 CN-23 CN-24 CN-24 CN-25 B P/N 951-6000519-02 A R2 R2 F1 F1 ATV SCHEMATIC, MC1000 A 8 7 6 5 4 3 2 1 ...