8 Twisted Shielded Pair (TSP) Connect Shield to Black #4 GND two places White (TSP) 70 White 62 Grey Wh/Blu(TSP) Green Black Green White Grey 55 10 99 Black 4 7 CN25 DCBA 6 5 4 3 2 1 H MC 1000 ECU Crank + P1 A1 O2 Sensor signal P1 A2 O2 sensor commonP1 A3 Crank P1 B1 Coolant Temp P1 B2 + 5 Vdc Supply P1 B3 P1 Sys on LED P1 C3 Air Temp P1 D1 Sensor Fail LED P1 D4 Stepper A P1 E1 Stepper B P1 E2 Throttle Position P1 E3 Sensor Ground P1 E4 Stepper D P1 F1 Stepper C P1 F2 Power Ground P1 G4 Fuel Pump P1 H1 Injector #2 P1 H2 Injector #1 P1 H3 +12V P1 H4 K Line L Line Map Select Trim Down Chassis Ground Trim Defeat Trim Up Vign Temp LED O2 Heater Power Latch Cooling Fan Cooling Fan Power Ground Power Ground Ignition Coil P2 A2 P2 B2 P2 B3 P2 C3 P2 C4 P2 D2 P2 D3 P2 E1 P2 E2 P2 F1 P2 F3 P2 G1 P2 G2 P2 G3 P2 G4 P2 H1 Break-out at (TPS) CN3 same length Break Out 3.5"at ECU Red Green Twisted Shielded Pair (TSP) Connect Shield to Black #4 GND two places CN24 SWITCH PANEL DIAGNOSTIC CONNECTOR Purple 1 1 Black 5 2 White 98 3 CN10 4 5 6 Green99 G P1 F2 P1 A1 P1 B3 P1 E3 P2 G2 P1 B1 P1 F4 P1 E4 P2 C4 P2 B2 P1 E1 P1 E2 P2 A2 P1 B2 P1 F1 P1 B4 P1 H4 P1 D1 P2 B3 P2 D2 P2 C3 P2 D3 P1 C3 P1 D4 P1 G4 P1 H1 P1 H3 P1 H2 P2 E2 P2 H1 P2 G3 P2 E1 P2 G4 P2 G1 P2 F3 P1 A2 P1 A3 P2 F1 Green Grey Black 24-2 Black 4 Black 15 Black 8 Black 7 Brown 24-1 Brown P1H4 Orange30 Black 13 Yellow 3 Yellow 2 Orange SP8 Purple 10-1 Red 20 Brown 49 30 87 Red 26 Yellow 1 Black 15 Black 14 SP12 Cooling Fan Blue R2 EMS/Vbatt Power BA BA BA CN18 CN19 CN23 21 Blue P2 Grey Connector P1 Black Connector 55 Green Green 54 Green 53 Green 52 SP11 98 63 +5 Vdc Splice SP2 Sensor GND H Grey Grey Grey Grey Grey Grey Grey Black Blue Blue Blue Blue Black Brown Black White (TSP) Wh/Blu(TSP) Blue 64 1 11 81 82 83 3 49 54 Black 14 Black 13 Black 5 64 G 21 Black 5 SP5 Battery GND SP4 Battery GND 21 1 SP6 +12 CN5 12 17 28 9 10 11 12 3 4 5 6 Air Temp Sensor Black 10 85 86 Red 26 33 83 Pencil Coil Spark Plug 12 Slide Connector Bullet Connector Ring Terminal CN22 Red F 84 71 CN8 SP3 BA BA AB Orange F 31 81 Blue BA D1-1N5408 BA CN6 21 Right Injector Injector SP12 Black Yellow 1 Yellow 2 Yellow3 Red L.Headlamp R. Headlamp Tail Lamp 12 Battery Lug O2 Sensor Battery Cable Twisted Shielded Pair AB Orange 31 Orange 32 Black 29 Cooling Fan CN21 Dead end and add HST to Wires for future Lambda sensor at deleted Cam Sensor Location White Black Green 1 SP9 Lights Orange 32 82 Blue E CN7 21 Left Injector Injector Brown 40 42 45 Female connector (sockets) Male connector (pins) Insulated Splice Pushbutton Red Black 29 E Yellow BA ECU Chassis Ground CN12 CN13 Violet Green 12 GREEN OFF RUN VIOLET YELLOW Diode 28 IGNITION SWITCH Black 50 BA CD Black RUN W/LTS 62 Grey 70 White 52 Green CN14 CN3 ABC TPS D Red D HARNESS CONN. I.D. 22 9 CBA CB 1 Red FUNCTION ECU ECU CRANK PICKUP THROTTLE POSITION SENSOR COOLANT TEMP. SENSOR AIR TEMP. SENSOR RIGHT INJECTOR LEFT INJECTOR IGNITION COIL DIAGNOSTIC DIAGNOSTIC COVER START BUTTON STOP BUTTON VOLTAGE REGULATOR STARTER SOLENOID FUEL PUMP VBATT + HEAD LAMPS HEAD LAMP TPA CLUTCH SWITCH IGNITION SWITCH COOLING FAN TAIL LAMP SWITCH PANEL SWITCH PANEL COVER STEPPER MOTOR RELAY BASE RELAY BASE TPA FUSE HOLDER FUSE HOLDER COVER CONNECTOR CINCH P/N 5800400001 32F CINCH P/N 5800400003 32F BLACK GREY AMP 963040-3 Jr. POWER TIMER PACKARD METRI-PACK CONN. 3F 12162182 AMP 963040-3 Jr. POWER TIMER AMP 963040-3 Jr. POWER TIMER AMP 963040-3 Jr. POWER TIMER AMP 963040-3 Jr. POWER TIMER FRAMATOME 211PC022S0021 DEUTSCH DTM SERIES DTM06-6S DEUTSCH DTM SERIES DTM04 0.156 INS. BULLET RECEPT. 1/4" RECESS 56139 QTY(2) 0.180 MALE BULLET CONN. 56128 OVER MOLD QTY(2) PACKARD WEATHER-PACK CONN. 4F 12015798 PACKARD METRI-PACK CONN. 2F 12162194 PACKARD WEATHER-PACK CONN. 2M 12010973 PACKARD WEATHER-PACK CONN. 2M 12010973 PACKARD METRI-PACK CONN. 2F 12020599 PACKARD METRI-PACK TPA 12034446 FEMALE TERMINAL SLIDE CONNECTOR MAGURA QTY(2) 0.156 INS. BULLET RECEPT. 1/4" RECESS 56139 QTY(3) PACKARD METRI-PACK CONN. 2F 15300027 PACKARD WEATHER-PACK CONN. 2M 12010973 DEUTSCH DTM SERIES DTM06-12S DEUTSCH DTM SERIES DTM04-12P PACKARD METRI-PACK CONN. 150.2 12162188 PACKARD METRI-PACK CONN. 5F 12033871 PACKARD METRI-PACK TPA 12033872 PACKARD 630 CONN. 2F 12085030 PACKARD COVER 12033731 12V, 8AH Batt Red 24 72 P1 P2 CN-2 CN-3 CN-4 CN-5 CN-6 CN-7 CN-8 CN-10 CN17 Red 72 Red 24 Red 74 SP7 Red 75 Red 73 Red 25 SP1 Vreg Red 21 BA Blue Black/Yellow 48 Black 45 BA Red Green Black CB 2 Start Button Stop Button Note: Stop Button is maintained opened or closed, Not Momentary Starter Solenoid Red CB 3 CN20 BA C CN4 Clutch Black 7 Black 5 Black50 Black 9 Grey A F1 - 20A 11 29 CN16 53 63 Coolant Temp Sensor 12 21 CN-10 CN-12 CN-13 CN-14 CN-15 CN-16 CN-17 CN-18,CN-19 M Fuel Pump AB C Frame Ground white/Blu(SP) BA Black Black/yellow CN15 48 White(TSP) M Starter Motor Twisted Shielded Pair Crank Pickup 8 CN2 12 21 B CN-18,19 CN-20 CN-21 CN-22 CN-23 CN-24 CN-24 CN-25 B A R2 R2 F1 F1 2002 ATV MC1000 Wiring Harness Schematic For Main Harness - P/N 6000668 (X-8) A 8 7 6 5 4 3 2 1 ...