DRAWER STYLE DISHWASHER USE & CARE GUIDE MODELS: DD224 Series Models DD124 Series Models INSTALLATION CHECKLIST Your installer MUST have completed and checked the following: The DishDrawer® is square and level. The DishDrawer® is fastened securely to the cabinetry. Ensure moisture protection tape has been applied and the cabinet is sealed according to the DishDrawer® Installation Instructions. The DishDrawer® opens and closes freely. The DishDrawer® must be free to close completely with no resistance from cabinetry. For the integrated models, check the 5/16" air gap has been achieved in the correct place. The power supply is connected and switched on. The inlet water hose is connected and turned on. There should be no leaks. The drain hose(s) are connected and there are no leaks. There must be no kinks, or obstructions in the drain hose(s). The spray arm is in the center and can freely rotate. The rinse program has been run. The water level will be below the stainless steel filter plate at the end of the wash program. It is normal to find some water in the drain filter area. Set the water softener to the correct water hardness for your area (DD224-H, DD124-H models only). Important! The installer is responsible for the DishDrawer® installation. Incorrect installation is not covered by warranty. IMPORTANT SAFETY INFORMATION SAVE THESE INSTRUCTIONS WARNING! For your safety, follow basic precautions when using your DishDrawer®, including the following: Please read all instructions before operating the DishDrawer®. The information in this manual must be followed to minimize the risk of fire or explosion or to prevent property damage, personal injury or loss of life. Use the DishDrawer® only for its intended function as described in this Use & Care. Use only detergents or rinse agent recommended for use in a domestic Dishwasher and keep them out of reach of children. Check that the detergent dispenser is empty after the completion of each wash program. When loading items to be washed locate sharp items so that they are not likely to damage the lid seal and load sharp knives with the handles up to reduce the risk of cut type injuries. Do not touch the heater plate during or immediately after use. Do not operate your DishDrawer® unless all the enclosure panels are properly in place. Do not tamper with the controls. Do not abuse, sit on, stand in or on the drawer or dish rack of the DishDrawer®. The cup racks are designed to support cups, glasses and kitchen utensils. When the cup racks are in the DishDrawer® do not lean on or use the cup racks to support your body weight. To reduce the risk of injury, do not allow children to play in or on the DishDrawer®. Under certain conditions hydrogen gas may be produced in a hot water heater system that has not been used for two weeks or more. HYDROGEN GAS IS EXPLOSIVE. If the hot water system has not been used for such a period, before using the dishwasher, turn on all hot water taps and let the water flow from each for several minutes. This will release any accumulated hydrogen gas. As gas is flammable, do not smoke or use an open flame during this time. Remove the door to the washing compartment when removing an old dishwasher from service or discarding it. Dishwasher detergents are alkaline. They can be dangerous if swallowed. Avoid contact with skin and eyes, keep children and infirm person(s) away from the dishwasher when the drawer is opened. INSTALLATION This DishDrawer® must be installed and located in accordance with the Installation Instructions before it is used. If you did not receive Installation Instruction sheets with your DishDrawer®, you can order them by calling your Authorized Service Agent. Installation and service must be performed by a qualified technician. If the power supply cord is damaged, it must be replaced by a dealer or Authorized Service Center or a similar qualified trades person in order to avoid a hazard. Ensure the DishDrawer® is secured to adjacent cabinetry using the brackets provided. Failure to do so may result in an unstable product, which may cause damage or injury. Do not operate this appliance if it is damaged, malfunctioning, partially disassembled or has missing or broken parts, including a damaged power supply cord or plug. Do not store or use petrol, or other flammable vapors and liquids in the vicinity of the DishDrawer®. Connect to a properly rated, protected and sized power supply circuit to avoid electrical overload. Make sure that the power supply cord is located so that it will not be stepped on, tripped over or otherwise subject to damage or stress. Do not install or store the DishDrawer® where it will be exposed to temperatures below freezing or exposed to weather. Do not use an extension cord or a portable electrical outlet device (e.g. multi socket outlet box) to connect the DishDrawer® to the power supply. MAINTENANCE Do not repair or replace any part of the appliance or attempt any servicing unless specifically recommended in this Use & Care. We recommend that you call an Authorized Service Agent. Keep the floor around your appliance clean and dry to reduce the possibility of slipping. Keep the area around/underneath your appliance free from the accumulation of combustible materials, such as lint, paper, rags and chemicals. When cleaning the underside of the filter plate, care must be taken on the sharp outer edge to avoid the risk of cut type injuries. OPERATIONAL Important! Under no circumstances should you open the drawer whilst the DishDrawer® is in operation. Always press the button to pause and wait until you hear the three additional beeps before opening the drawer. The DishDrawer® must be used with the motor assembly, filter plate, drain filter and spray arm in place. When disconnecting the appliance pull the plug rather than the power supply cord or junction of cord to avoid damage. Take care when loading the DishDrawer® not to load dishware items so it prevents the lid from properly sealing with the drawer. Items should be placed so they do not protrude above and/or forced into the drawer, otherwise a service call may result. Household appliances are not intended to be played with by children. Children or persons with a disability which limits their ability to use the appliance, should have a responsible person instruct them in its use. The instructor should be satisfied that they can then use the appliance without danger to themselves or their surroundings. Close supervision is necessary if this appliance is used by or near children. Do not allow children to play inside, on or with this appliance or any discarded appliance. If a Dishwasher cleaner is used, we would strongly recommend a wash program with detergent should be run immediately afterward, to prevent any damage to the DishDrawer®. The DishDrawer® is designed for washing normal household utensils. Items that are contaminated by petrol, paint, steel or iron debris, corrosive, acidic or alkaline chemicals are not to be washed in the DishDrawer®. If the DishDrawer® is not being used for long periods of time, turn the electricity and water supply to the DishDrawer® off. Do not pour detergent or rinse agent into the salt reservoir. The detergent or rinse agent will destroy the water softener. Important! This Use & Care should be retained with the appliance for future reference. Should the appliance be sold or transferred to another owner, always ensure that the Use & Care is left with the appliance in order that the new owner can become familiar with the appliance and the relevant warnings. DISHDRAWER® USE & CARE CONTENTS Installation checklist Important safety information Controls Operation Wash program chart Caring for your dinnerware Dishwasher standards test Accessories Loading Detergent dispenser Water softener Rinse agent dispenser Option adjustment User maintenance instructions Trouble shooting Fault codes Limited warranty DishDrawer® Single DD124 Series 2 4 5 6 7 8 10 12 14 16 17 19 22 25 26 This Use & Care explains how to operate and maintain your new appliance properly and safely. Please read the whole guide carefully before starting to use your appliance. DishDrawer® Double DD224 Series Your product may differ slightly from the diagrams in this book. CONTROLS If you have a double DishDrawer®, each drawer has its own controls and can run independently of the other. POWER BUTTON The button turns the DishDrawer® on or off. Opening the drawer will automatically turn the DishDrawer® on for 30 seconds. To end a wash program in mid cycle, press the button. Any water in the DishDrawer® will be pumped out. Control buttons START/PAUSE BUTTON The button starts a wash program. Press the button to pause or restart the DishDrawer® during a wash program. When paused, wait for three beeps before opening the drawer. Forcing the drawer open while in mid cycle may cause damage or injury. DELAY START The button also sets the Delay Start feature which can delay the start of a wash program from 1 to 12 hours. This feature also satisfies Shabbat requirements if the Auto Power option is disabled (see Option Adjustment). To activate Delay Start 1 2 Press and hold the button until the light above the button turns purple. Continue holding the button down until the desired delay time has been reached. The DishDrawer® will emit audible `beeps' as you hold the button down, each beep indicates another hour delay. The DishDrawer® will start once the delay time has elapsed and the drawer is closed. 3 To cancel Delay Start Press the button. 2 LOCK BUTTON The OPTIONAL button activates/deactivates the Keylock or the Childlock functions. Keylock The Keylock feature disables all the buttons on the DishDrawer®. To activate, press and hold the button until you hear one beep (3 seconds). The light above the button is lit when Keylock is activated. To cancel the Keylock feature, press and hold the button disappears. button until the light above the Childlock The Childlock feature locks the drawer and disables all the buttons. To activate, press and hold the button until you hear two beeps (5 seconds). The light above the button is lit when Childlock is activated. To cancel the Childlock feature, press and hold the the button disappears. button until the light above WASH PROGRAM SELECTOR Press the button to select a wash program. The DishDrawer® will remember the last program used. ECO BUTTON OPTIONAL Press the button if you would like the wash program to use less energy and time. The red ECO light will indicate the feature is on. If your dishes are heavily soiled or you require enhanced dry performance, we do not recommend ECO programs. POWER FAILURE If the DishDrawer® is operating and a power failure occurs, it will stop. The DishDrawer® may be unable to be opened during this time. When the power supply is resumed, the DishDrawer® will restart in the same part of the wash program. 3 OPERATION 1 Load Dishes Remove all food scraps and load the dishes. Add Detergent Check Rinse Agent Press the Button 7 Start Close the drawer and press the button. Finish The DishDrawer® will beep six times to indicate the end of the wash program. At the end of the wash program the drying fan will continue to run for a set time or until the drawer is opened. The fan assists with drying and uses negligible amounts of energy. It is normal for some water to remain in the drain filter area after the wash program is complete. 2 3 4 5 6 8 Select a Wash Program Check Ensure there is nothing obstructing the spray arm. The drain filter must be level with the filter plate. 2 3 1 6 5 4 4 7 WASH PROGRAM CHART Standard Wash Program - when to use Heavy Heavily soiled pots, pans and dishes. Normal Dishes with normal soils for optimum wash and dry performance. Fast Lightly soiled dishes. Delicate Lightly soiled and heat sensitive crockery. Rinse Prevents odors and soils drying on dishes. pre wash 1 pre wash 2 main wash 150oF post rinse 1 post rinse 2 final rinse 163oF drying phase pre wash 1 pre wash 2 main wash 145oF post rinse final rinse 140oF drying phase main wash 130oF post rinse final rinse 120oF pre wash main wash 120oF post rinse final rinse 130oF drying phase pre wash Eco Wash Program - when to use Heavy Heavily soiled everyday dishes. Normal Normal soiled dishes for optimum energy use. Fast Lightly soiled, non greasy dishes. Delicate Lightly soiled, non greasy and heat sensitive crockery. pre wash 1 pre wash 2 main wash 150oF post rinse 1 post rinse 2 final rinse 150oF drying phase pre wash main wash 130oF post rinse final rinse 130oF drying phase main wash 115oF post rinse final rinse 115oF pre wash main wash 115oF post rinse final rinse 120oF drying phase note Wash times can vary depending on the incoming water temperature, ambient conditions, type of dish load and whether the drawer has been opened during the wash. 5 CARING FOR YOUR DINNE ...