XDVD8181 INSTALLATION/OWNER'S MANUAL DVD Multimedia Receiver with 7" Touch Screen Display TOUCH Safety Note: The DVD video display of the in-dash unit will not operate while the vehicle is moving. This is a safety feature to prevent driver distraction. In-dash DVD video functions will only operate when vehicle is in Park and the parking brake is engaged. It is illegal in most states for the driver to view video while the vehicle is in motion. XDVD8181 PREPARATION Table of Contents Page DVD Region Management . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Safety Information/Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Preparation/Mounting/Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-7 Control Locations - Monitor Close . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-9 Control Locations - Monitor Open . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10-11 Control Locations - Remote . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-13 General Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-19 System Setup Menu . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0-1 Setting the Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Anti-theft Code . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 System Screen Setup. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-7 AM/FM Tuner Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-9 DVD Operation Menu . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30-37 DVD Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38-40 SVCD Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41 CD Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-43 MP3/WMA Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44-45 Media Compatibility . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46-47 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48 Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49 Notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50 Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51 DVD Region Management Some DVD discs can be played only in certain playback modes according to the intentions of the software. As the XDVD8181 plays discs according to their intentions, some functions may not work as intended. Please be sure to read the instructions provided with each disc. This player has been designed to play back DVD software that has been encoded for specific region areas. It cannot play back DVD software encoded for other region areas than the region areas for which it has been designed. The XDVD8181 will play discs labeled "Region 1" or "All". DVD region codes: 1 - USA, Canada - Japan, Europe, South Africa, Middle East 3 - Rep. of Korea, Taiwan, Hong Kong, Parts of Southeast Asia 4 - Australia, New Zealand, Mexico, South America 5 - Eastern Europe, Russia, India, Africa 6 - China XDVD8181 PREPARATION Safety Information Please read all instructions carefully before attempting to install or operate. Due to its technical nature, it is highly recommended that your DUAL XDVD8181 is installed by a professional installer or an authorized dealer. This product is only for use in vehicles with 1VDC negative ground only. Safety Notes: The DVD video display of the in-dash unit will not operate while the vehicle is moving. This is a safety feature to prevent driver distraction. In-dash DVD video functions will only operate when vehicle is in Park and the parking brake is engaged. It is illegal in most states for the driver to view video while the vehicle is in motion. To prevent damage or injury: 1. . 3. 4. 5. Make sure to ground the unit securely to the vehicle chassis ground. Do not remove the top or bottom covers of the unit. Do not install the unit in a spot exposed to direct sunlight or excessive heat or the possibility of water splashing. Do not subject the unit to excessive shock. When replacing a fuse, only use a new one with the prescribed rating. Using a fuse with the wrong rating may cause the unit to malfunction. 6. To prevent short circuits when replacing a fuse, disconnect the wiring harness first. 7. Use only the provided hardware and wire harness. 8. You cannot view video while the vehicle is moving. Find a safe place to park and engage the parking brake. 9. If you experience problems during installation, consult your nearest DUAL dealer. 10.If the unit malfunctions, reset the unit as described on page 11 first. If the problem still persists, consult your nearest DUAL dealer or call tech assistance @ 1-866-38-5476. 11.To clean the monitor, wipe only with a dry silicone cloth or soft cloth. Do not use a stiff cloth, or volatile solvents such as paint thinner and alcohol. They can scratch the surface of the panel and/or remove the printing. 1.When the temperature of the unit falls (as in winter), the liquid crystal inside the screen will become darker than usual. Normal brightness will return after using the monitor for a while. Additional notes: 1. When extending the ignition, battery or ground cables, make sure to use automotive-grade cables or other cables with an area of 0.75mm (AWG 18) or more to prevent voltage drops. . Do not touch the liquid crystal fluid if the LCD is damaged or broken. The liquid crystal fluid may be hazardous to your health or fatal. If the liquid crystal fluid from the LCD contacts your body or clothing, wash it off with soap immediately. This device complies with part 15 of the FCC rules and regulations. Operation is subject to the following two conditions: 1) This device may not cause harmful interference, and ) This device must accept any interference received, including interference that may cause undesired operation. 3 XDVD8181 INSTALLATION Preparation Please read entire manual before installation. Before You Start · Disconnect negative battery terminal. Consult a qualified technician for instructions. · Avoid installing the unit where it would be subject to high temperatures, such as from direct sunlight, or where it would be subject to dust, dirt or excessive vibration. Getting Started · Remove the four #1 phillips head screws from each corner, and slide the unit out of the mounting sleeve. · Install mounting sleeve into opening, bending tabs to secure. · Connect wiring harness and antenna as shown on pages 5-6. Consult a qualified technician if you are unsure. · Certain vehicles may require an installation kit and/or wiring harness adapter (sold separately). · Test for correct operation and slide unit into mounting sleeve, secure with #1 phillips screws as removed in step 1. · Snap trim ring into place. · Mount the iplugTM adapter to any smooth clean surface using the supplied double-sided tape or # x 3/8" Phillips head screws. Mounting sleeve opening dimensions 7-3/16" x -1/16" (183 mm x 53 mm) TYPICAL FRONT-LOAD DIN MOUNTING METHOD 4 XDVD8181 INSTALLATION Expanded Wiring Diagram - Inputs/Outputs OPTIONAL HEADREST MONITOR OPTIONAL TFT MONITOR OPTIONAL BACKUP CAMERA YELLOW / BLUE EMERGENCY BRAKE SWITCH BATTERY + YELLOW GROUND BLACK ACC POWER ANTENNA AMP REMOTE BLUE / WHITE RED REVERSE WHITE / BROWN Wiring Notes: Subwoofer output The SUBWOOFER audio output (Blue RCA) is active in all audio modes and must be connected to an external amplifier. Rear view camera A rear view camera (not included) can be used with CAMERA input. NEED HELP?? Call our Technical Service Hotline, 1-866-38-5476 Safety Note: The DVD video display of the in-dash unit will not operate while the vehicle is moving. This is a safety feature to prevent driver distraction. In-dash DVD video functions will only operate when vehicle is in Park and the parking brake is engaged. It is illegal in most states for the driver to view video while the vehicle is in motion. Altering or defeating this safety feature is a violation of law and is prohibited. 5 XDVD8181 INSTALLATION Wiring Diagram - Optional A/V Connections 6 XDVD8181 OPERATION IR Remote Preparation To first use the IR Remote control, you must first pull the battery insulation tape out NOTE: · Remove the battery if the IR Remote will not be used for a month or longer · Remove and dispose of battery properly Insert / Replacing the Battery: Remove the battery holder Remove the battery from the battery holder Install the new battery Make sure to keep the (+) side up Insert the battery holder · CAUTION!!! Do not store battery with metallic objects or materials 7 XDVD8181 OPERATION Control Locations - Monitor Closed 1 2 3 4 5 6 16 15 14 13 12 11 10 9 8 7 1 2 3 4 5 6 7 8 Band Auto Store/Preset Scan Secondary LCD Display Open/Close Monitor Eject Rotary Encoder / Enter Mode 9 Chapter/Track Up 10 Chapter/Track Down 11 Stop 12 Play/Pause 13 Fast Forward 14 Fast Reverse 15 Mute 16 Power/Volume Monitor Notes: · · · This model incorporates a motorized moving monitor. Before final installation, make sure the monitor will not obstruct the dash, shifter or any other controls. Upon installation, do not attempt to move the monitor up/down by hand. Use the ANGLE / and OPEN buttons on the front panel only. The unit will stop if it encounters any obstacles during the open/close sequence. If this occurs, remove the obstacle and press OPEN again to resume the monitor open/close sequence. 8 XDVD8181 OPERATION Control Functions - Monitor Closed BAND AS/PS (Auto Store /Preset Scan) SECONDARY LCD DISP OPEN Press BAND to increment from FM1, FM, FM3, AM1] FM1. Press AS/PS for 1 sec to start station PRESET SCAN function, Press AS/PS for secs to start AUTO STORE station preset function in current BAND. Additional LCD for system information while monitor is closed. Press the DISP button to display CLOCK information on the secondary LCD screen when the monitor is closed. Press OPEN to open or close the monitor. The unit will emit 1 confirmation beep upon opening, 3 beeps when closing. Be careful not to not touch or obstruct the monitor movement during the open/close sequence, or permanent damage could occur. Press once for DISC ejection. Press to access MAIN menu, rotate clockwise/counter clockwise to select desired item and press once to ENTER. Press once to incrementally select desired source. Selects the next chapter/track for playback. Selects the previous chapter/track for playback. Stop playback of DVD / CD / MP3 / . Press once for PAUSE, press again for PLAY. Fast forward the disc content. Fast reverse the disc content. Press once to MUTE audio, press again to return audio, an icon indicator will flash on the TFT monitor. Press Volume knob for 1sec to turn the unit on, the unit will beep times. Press and hold POWER for more than secs, unit will beep 3 time, then turn off. NOTE: EJECT will still function even if POWER is off. Rotate clockwise/counter clockwise for desired VOLUME level, press once to access the AUDIO SETUP MENU. EJECT ROTARY MODE TRACK UP TRACK DOWN STOP PLAY/PAUSE FAST FORWARD FAST REVERSE MUTE POWER ON/OFF VOLUME 9 XDVD8181 OPERATION Control Locations - Monitor Open 1 2 3 4 5 1 Disc-in indicator - Red = Disc inserted, Blue = No disc . 2 ANGLE - Press to decrease the monitor view angle. 3 ANGLE - Press to increase the monitor view angle. 4 INFO - Press to select system INFO and press and hold for BRIGHTNESS. 5 Press to RESET system. Safety Notes: The DVD video display of the in-dash unit will not operate while the vehicle is moving. This is a safety feature to prevent driver distraction. In-dash DVD video functions will only operate when vehicle is in Park and the parking brake is engaged. It is illegal in most states for the driver to view video while the vehicle is in motion. 10 XDVD8181 OPERATION Control Functions - Monitor Open Disc-in indicator Blue = No disc Red = Disc inserted Monitor Angle Press ANGLE to increase the monitor view angle. Press ANGLE to decrease the monitor view angle. Notes: · Do not attempt to move the monitor up/down by hand - severe damage will occur. Use the front panel buttons or the remote control only. · The color of the LCD monitor varies betw ...