User manual ELECTROLUX EIW60000X

REFRESHMENT CENTER Built-in appliance EIW60000X welcome to the world of Electrolux electrolux 3 Welcome to the world of Electrolux Thank you for choosing a first class product from Electrolux, which hopefully will provide you with lots of pleasure in the future. The Electrolux ambition is to offer a wide variety of quality products that make your life more comfortable. You find some examples on the cover in this manual. Please take a few minutes to study this manual so that you can take advantage of the benefits of your new machine. We promise that it will provide a superior User Experience delivering Ease-ofMind. Good luck! 4 electrolux contents Contents Electrical safety ........................ 5 Electrical safety .................... 5 Installation........................... 6 Use .................................... 6 Cleaning .............................. 6 Environment ......................... 6 Appliance description.................. 7 Units .................................. 7 Identification plate (Fig. 2) ........... 8 Technical Characteristics ............. 8 Installation .............................. 9 Installation steps: .................. 9 Package content .................... 9 1 Unit positioning ................. 9 2 Water mains and siphon connection ..................... 10 3 Install filter cartridge ........ 11 4 Startup ......................... 12 Using the Refreshment Unit..... 13 Front touch panel................. 13 Dispensing.......................... 13 Alarms .................................. 14 Maintenance........................... 16 CO2 bottle replacemen .......... 16 Sanification + filtration cartridge17 Environment care..................... 19 Electric diagram ...................... 20 Hydraulic diagram .................... 21 Guarantee/Customer Service....... 22 The following symbols are utilized with this manual: Safety information Environment Disposal directives electrical safety electrolux 5 Electrical safety This appliance conforms to the following safety electrical European Directives: This manual has been written for your own safety and of others. Please read manual carefully before installation and/or use. Please keep this instruction manual in a safe and dry place. This appliance conforms to the following safety electrical European Directives: 73/23/CEE, 89/336/CEE, 92/31/CEE, 98/37/CEE. Please keep this instruction manual in a safe and dry place. This manual has been written for you own safety and of others. Please read manual carefully before installation and/or use. Electrical safety The unit needs to be connected to a power supply line that conforms fully to local safety regulations regarding electrical safety. If in doubt please have your electrical system checked by a specialized electrician. Please do not try to repair the unit as you might cause additional damage. Contact your nearest Technical assistance center. Remove power supply cord before proceeding with repair operations. If the power supply cord appears to be damaged, please ask for a replacement cord. 6 electrolux appliance description Installation Please handle appliance with care to prevent damaging of the refrigeration circuit. Avoid prolonged exposure of the appliance to direct sunlight. To guarantee maximum stability and safety, it's necessary to install the builtin appliance only in AEG, REX and Electrolux sized cabinets. Please follow instruction carefully before, during and after installation. If the appliance is transported in vertical position, please place in horizontal (normal) position and wait 1 hour for the oil to return to the compressor before turning unit on. Do not bend water supply and discharge tube excessively during installation. Use Do not use the Refreshment Unit for something else other than dispense cold, carbonated, ambient water and ice. An incorrect use of the appliance may harm people or cause damage to the appliance itself. Do not allow children to use the appliance if not under the supervision of adults. Cleaning Do not use metallic tools to clean the appliance as it may cause damage. Environment Please follow local disposal regulations. appliance description electrolux 7 Appliance description The Refreshment Unit is a domestic appliance designed to dispense purified cold, carbonated and ambient temperature water and icecubes. The appliance has 2 outlet from which the following products can be 1 23 4 5 6 dispensed: - Ambient temperature water - Cold water - Carbonated water - Ice-Cubes. 7 89 Units The unit is mainly composed of: 1 St. Steel front display 2 Filter head 3 Water dispense nozzle 4 5 Glass touch command panel Ice dispense outlet 10 11 12 13 6 7 8 9 Drip tray CO2 bottle H2O pressure regulator with gauge Filter cartridge 10 11 12 13 Power supply socket Main on/off switch H2O inlet H2O drainage 8 electrolux identification plate Identification plate (Fig. 2) Should you need to contact a technical Assistance Center, make sure you have the serial number handy for identification. The serial number is on the identification plate in the side of the appliance. Extract from cabinet to identify plate. MODEL TYPE XXXXXXXX 230 V ~ 50 Hz MAX 190 W PNC xxx xxx xxx SERIAL No.: Refreshment Center xxxxxxxx MADE IN ITALY Fig. 2 Technical Characteristics Power Supply Frequency Power consumption Cold water dispense capacity Carbonated water dispensecapacity Dispense temperature Water mains pressure (water inlet) CO2 pressure Filtration Filter capacity Ambient temperature conditions range Unit dimensions L x P x H (mm) Weight Refrigerant gas 230-240 V 50 Hz 190 W 2lt @ 1 l/min. 2lt @ 1 l/min < 13°C > 2.0 bar 2.5-4 bar 0.5 micron 3000 litres 18°C-32°C 594x530xH378 38 Kg R134a ­ 60gr installation electrolux 9 Warning In order for the unit to work correctly, the Technical Characteristics specification chart on page 6 needs to be observed. Installation steps: 1. Refreshment unit assembly inside kitchen 2. Water mains connection 3. Water filter connection 4. Electric power supply Installation Power supply cord H2O inlet flexible hose and discharge tube Filtration Cartridge Package content Open package and immediately check for any transport damages. During installation please handle with care. Inside you should find the following material: A. Refreshment Center B. 2 Sliding Rails C. Mounting base plate D. 6 spacers 2x1mm, 2x2mm, 2x3mm Sanitazing cartridge and liquid 1 Unit positioning A B C D Please install unit as far away as possible from heat sources Install the mounting base plate inside the kitchen cabinet after checking after checking dimension requirements as shown in Fig. 4. Mount the 2 sliding rails onto the base plate. Place the Refreshment Center on the sliding rails. 10 electrolux installation 360 580 564 Fig. 4 2 Water mains and siphon connection Warning Connect only to potable water mains. All water mains connections should be carried out by a certified plummer. Warning Water mains pressure can be set through the H2O pressure regulator placed near the CO2 bottle. Pressure should be no higher than 3.0 bars and no lower than 2.0 bars. Complete following operations (Fig. 5): - Connect the flexible hose to the H2O inlet on the unit. Connect water mains to flexible hose. - Connect discharge tube to discharge barbed connection on unit and to sink siphon. Fig. 5 installation electrolux 11 3 Install filter cartridge Lift locking spring placed under drip tray (Fig. 5a). Fig. 5a Pull unit from cabinet. On the left side of the unit please find the filter cartridge (Fig. 6). Filter cartridge Fig. 6 Remove filter plastic cap and install filter in filter head as shown on filter instruction booklet (Fig. 7). Fig. 7 Verify the on/off valve near the reducer is closed Check for water leaks and make sure the CO2 bottle is tightly fixed on the CO2 pressure regulator. Open the pressure regulator valve and set pressure to 3 bars on gauge. Pressure can be increased to 4 bars to increase carbonation levels (Fig. 9). Fig. 9 12 electrolux installation 4 Startup Warning Before plugging unit to power supply, please check for correct power supply voltage and frequency as stated on Technical Characteristic chart (see page 6). Fig. 10 which will take approx. 4 minutes. Connect unit to 230V through supplied cord. This preliminary operation will be Electric supply circuit should conform carried out every time the unit is turned off and on through the main to local laws and regulations. on/off switch inside the cabinet. Warning During this process the touch control The supplier declines any panel is inactive. responsibility should any safety rule not be respected during installation. After 4 minutes turn unit on through Turn unit on through main on/off on/off button on touch control panel switch on side of unit. The unit will to activate all functions. undergo an initialization process At this point please wait approx. 3 hours before the unit reaches final working temperatures in order to dispense cold water, carbonated water and ice-cubes. Ambient water is readily immediately. installation electrolux 13 Using the Refreshment Unit Front touch panel 1 2 3 4 5 6 7 8 1 Empty CO2 bottle led 2 On/Off switch 3 Water ambient temperature button 4 Carbonated water button 5 Cold water button 6 Ice dispense button 7 Light button On/Off 8 Exhaust filter led Dispensing After turning appliance on through on/off switch on touch screen, wait for cooling time before dispensing. Place a glass under dispense nozzle. Press button corresponding to desired selection. Release until desired dispense water level or number of icecubes is reached. Please do not dispense more than 1 liter of carbonated water continuously since you might experience CO2 exhaust from nozzle. Should that occur, please wait 1 minute and restart dispensing carbonated water. 14 electrolux alarms Dispensing is signalled by the corresponding led. In order to dispense in bottles or carafes, please extract dispense nozzle by grabbing on sides of nozzle and pulling forward. Alarms Led indications Led blinks slowly Message Filter is about to exhaust. 2900 liters have been dispensed. Please change filter as described in the following chapters. Led is lit Filter is about to exhaust. 2980 liters have been dispensed. Please change filter as described in the following chapters. Led is lit All dispense buttons disabled. 3000 liters have been reached. Please change filter as described in the following chapters. alarms electrolux 15 Carbonated water led blinks slowly Carbonated water is disabled. Time-out protection on carbonation pump activated. To reset status please turn unit off/on on touch control panel. Carbonated water is disabled. CO2 bottle is empty. Replace CO2 bottle to restore Carbonated water dispensing. Please change CO2 bottle as described in the following chapters. CO2 bottle led on Leds - ambient water - ice blink simultaneously Ice forming bin blocked. Turn unit on/off through main on/off switch on side of unit. Leds - ambient water - cold water - carbonated water blink simultaneously Leds - carbonated water - ambient water - cold water - ice blink simultaneously Volumetric turbine malfunctioning. Dispense functions enabled but during dispense operation the 3 leds will blink. Main water tank fill time-out. Please check water supply to unit. Make sure filter shut off valve to be open. To reset status turn unit on/off through main switch inside cabinet. 16 electrolux maintenance All leds on simultaneously All dispense buttons disabled. 2 main causes: 1. Water present on base of unit. Possible leak. 2. Water level too high inside water tank. Water discharge blocked. For the first case switch off and dry the base of the unit. For the second case turn unit on/off through main switch inside cabinet. Should alarms repeat themselves after all restart attempts, please call service assistance. Maintenance Before any maintenance or cleaning procedure, please switch off the appliance and disconnect it from main by unplugging the power plug. CO2 bottle replacement When the CO2 led turns on, it's necessary to replace the CO2 bottle as described below: 1. Pull appliance from cabinet (A-Fig. 12). 2. Grab the CO2 bottle and extract it from it's locking clip. 3. By holding the bottle fixed, turn the pressure regulator clockwise to remove from the bottle (fig. 13). Fig. 12 maintenance electrolux 17 4. Place new bottle under the regulator and screw counter clockwise till fully tightened. 5. Lock bottle in place and close cabinet. Fig. 13 Sanification + filtration cartridge When the exhaust filter led turns on, it is time to replace the filter cartridge: 1. Turn unit off through main on/off switch (Fig. 11). 2. Pull unit from cabinet (Fig. 5a) and look for two shot off valves on the base of the unit under the CO2 cylinder. 3. Close valve (Fig. 14). 4. Unwind the wrapped tube to a container or glass and open valve 1 to relieve filter pressure (Fig. 14a). This operation will ease the filter cartridge removing operation. 5. Remove the filter cartridge form its housing by rotating counter clock-wise about a quarter turn (Fig. 15). This will free the filter. Pull downward and remove it. 6. Fill sanitizing cartridge with 300cc of Neutal Detergent. Insert the sanitizing cartridge on the filter head by rotating clock-wise a quarter turn. 7. Open valve near the water pressure reducer (Fig. 8). 8. Dry any water from the base, that could have leaked during this operation. 9. Position under the water dispense nozzle a container or large cup. 10. Turn main switch. Wait approx. 5 seconds and press "light" button until 18 electrolux maintenance sanitizing mode is entered. This will be shown in the display as a moving red led through all the buttons. During this operation, the inside of the unit will be sanitized. After this initial cleaning cycle, the unit will dispense automatically some cold and ambient water. Shut off unit from main on/off switch. Close valve on base if unit (Fig. 14). Position under the water dispense nozzle a container and dispense water to empty sanitize cartridge and tubes Install new filter cartridge as shown on filter cartridge instructions (Fig. 7). Wait 4 minutes before turning unit on through the touch button. Dispense 1 liter of cold, ambient and carbonated water to fully rinse any sanitizing residue. 11. 12. 13. 14. 15. 16. Fig. 15 The following is a troubleshooting section for malfunctions that are not in the Alarms list above: SYMPTOM Water is not dispensed PROBABLE CAUSE No power supply Water mains inlet solenoid valve failure Probabile refrigerant ga leak Motor fan failure Compressor failure RESOLUTION Check electric power supply Call technical assistance Call technical assistance Call technical assistance Call technical assistance The unit has been on for over 3 hours, but no cold water nor ice is available enviromnet care electrolux 19 Low carbonation level Brand new appliance Low CO2 pressure Utilize for few days and check carbonation Increase CO2 pressure by rotating knob on CO2 pressure regulator clock-wise Dispense few litres of carbonated water and check carbonation Call technical assistance Air inside carbonator Cold water occasionally sprays CO2 gas Non return valve on carbonator dirty Warning All repairs should be carried out by authorized technicians. Environment care The symbol on the product or on its packaging indicates that this product may not be treated as household waste. Instead it shall be handed over to the applicable collection point for the recycling of electrical and electronic equipment. By ensuring this product is disposed of correctly, you will help prevent potential negative consequences for the environment and human health, which could otherwise be caused by inappropriate waste handling of this product. For more detailed information about recycling of this product, please contact your local city office, your household waste disposal service or the shop where you purchased the product. 20 electrolux electric diagram Electric diagram hydraulic diagram electrolux 21 Hydraulic diagram 22 electrolux guarantee/customer service Guarantee/Customer Service Standard guarantee conditions We, Electrolux, undertake that if within 12 months of the date of the purchase this Electrolux appliance or any part thereof is proved to be defective by reason only of faulty workmanship or materials, we will, at our option repair or replace the same FREE OF CHARGE for labour, materials or carriage on condition that: - The appliance has been correctly installed and used only on the electricity supply stated on the rating plate. - The appliance has been used for normal domestic purposes only, and in accordance with the manufacturer's instructions. - The appliance has not been serviced, maintained, repaired, taken apart or tampered with by any person not authorised by us. - Electrolux Service Force Centre must undertake all service work under this guarantee - Any appliance or defective part replaced shall become the Company's property. - This guarantee is in addition to your statutory and other legal rights. Exclusions - Damage or calls resulting from transportation, improper use or neglect, the replacement of any light bulbs or removable parts of glass or plastic. - Costs incurred for calls to put right an appliance which is improperly installed or calls to appliances outside the United Kingdom. - Appliances found to be in use within a commercial environment, plus those which are subject to rental agreements. - Products of Electrolux manufacturer that are not marketed by Electrolux Service and Spare Parts In the event of your appliance requiring service, or if you wish to purchase spare parts, please contact your local Service Force Centre by telephoning 0870 5 929 929 Your telephone call will be automatically routed to the Service Force Centre covering your postcode area. For the address of your local Service Force Centre and further information about Service Force, please visit the website at www.serviceforce.co.uk Before calling out an engineer, please ensure you have read the details under the heading "Something not working" When you contact the Service Force Centre you will need to give the following details: 1. Your name, address and postcode. 2. Your telephone number. 3. Clear concise details of the fault. 4. The model and Serial number of the appliance (found on the rating plate). 5. The purchase date. Please note a valid purchase receipt or guarantee documentation is guarantee/customer service electrolux 23 required for in guarantee service calls. 24 electrolux guarantee/customer service Customer Care For general enquiries concerning your Electrolux appliance, or for further information on Electrolux products please contact our Customer Care Department by letter or telephone at the address below or visit our website at www.electrolux. co.uk Customer Care Department Electrolux Major Appliances Addington Way Luton Bedfordshire, LU4 9QQ Tel: 08705 950 950 (*) (*) Calls may be recorded for training purposes guarantee/customer service electrolux 25 European Guarantee This appliance is guaranteed by Electrolux in each of the countries listed at the back of this user manual, for the period specified in the appliance guarantee or otherwise by law. If you move from one of these countries to another of the countries listed below the appliance guarantee will move with you subject to the following qualifications: - The appliance guarantee starts from the date you first purchased the appliance which will be evidenced by production of a valid purchase document issued by the seller of the appliance. - The appliance guarantee is for the same period and to the same extent for labour and parts as exists in your new country of residence for this particular model or range of appliances. - The appliance guarantee is personal to the original purchaser of the appliance and cannot be transferred to another user. - The appliance is installed and used in accordance with instructions issued by Electrolux and is only used within the home, i.e. is not used for commercial purposes. - The appliance is installed in accordance with all relevant regulations in force within your new country of residence. The provisions of this European Guarantee do not affect any of the rights granted to you by law. 26 electrolux guarantee/customer service www.electrolux.com Albania Belgique/België/ Belgien Èeská republika +35 5 4 261 450 +32 2 363 04 44 +420 2 61 12 61 12 Rr. Pjeter Bogdani Nr. 7 Tirane Bergensesteenweg 719, 1502 Lembeek Budìjovická 3, Praha 4, 140 21 Danmark Deutschland Eesti España France Great Britain Hellas Hrvatska Ireland Italia Latvija Lietuva Luxembourg Magyarország +45 70 11 74 00 +49 180 32 26 622 +37 2 66 50 030 +34 902 11 63 88 www.electrolux.fr +44 8705 929 929 +30 23 10 56 19 70 +385 1 63 23 338 +353 1 40 90 75 +39 (0) 434 558500 +37 17 84 59 34 +370 5 2780609 +35 2 42 43 13 01 +36 1 252 1773 Sjællandsgade 2, 7000 Fredericia Muggenhofer Str. 135, 90429 Nürnberg Mustamäe tee 24, 10621 Tallinn Carretera M-300, Km. 29,900 Alcalá de Henares Madrid Addington Way, Luton, Bedfordshire LU4 9QQ 4 Limnou Str., 54627 Thessaloniki Slavonska avenija 3, 10000 Zagreb Long Mile Road Dublin 12 C.so Lino Zanussi, 26 33080 Porcia (PN) Kr. Barona iela 130/2, LV-1012, Riga Verki 29, LT_09108 Vilnius Rue de Bitbourg, 7, L-1273 Hamm H-1142 Budapest XIV, Erzsébet királyné útja 87 Nederland Norge Österreich Polska +31 17 24 68 300 +47 81 5 30 222 +43 18 66 400 +48 22 43 47 300 Vennootsweg 1, 2404 CG - Alphen aan den Rijn Risløkkvn. 2 , 0508 Oslo Herziggasse 9, 1230 Wien ul. Kolejowa 5/7, Warsaw Portugal Romania +35 12 14 40 39 39 +40 21 451 20 30 Quinta da Fonte - Edificio Gonçalves Zarco - Q 352774 - 518 Paço de Arcos Str. Garii Progresului 2, S4, 040671 RO Schweiz/Suisse/ Svizzera Slovenija Slovensko +41 62 88 99 111 +38 61 24 25 731 +421 2 43 33 43 22 Industriestrasse 10, CH-5506 Mägenwil Electrolux Ljubljana, d.o.o.Trzaska 132, 1000 Ljubljana Electrolux Slovakia s.r.o., Electrolux Domáce spotrebièe SK, Seberíniho 1, 821 03 Bratislava Suomi Sverige Türkiye P +35 8 26 22 33 00 +46 (0)771 76 76 76 +90 21 22 93 10 25 +7 495 9377837 Konepajanranta 4, 28100 Pori Electrolux Service, S:t Göransgatan 143,S105 45 Stockholm Tarlabaþý caddesi no : 35 TaksimIstanbul 129090 , , 16, , ,," Prokom Gesellschaft für Gebrauchsanweisungen mbH Muggenhofer Straße 135 D-90429 Nürnberg http://www.aeg-electrolux.de © Copyright by AEG 822 612 226-00-240105-02 Subject to change without notice