Upright Vacuum Cleaner Household Type IMPORTANT Do not return this product to the store. For assembly problems or questions contact: Eureka's Customer Service Division toll free at 1-800-282-2886*, 8 a.m. to 7:30 p.m., (CST), Monday Friday and 10 a.m. - 6:30 p.m. (CST) Saturday. For replacement of broken or missing items to be shipped direct to you, call 1-800-438-7352*, 8 a.m. to 4:45 p.m., Central Standard Time, Monday through Friday. *En Mexico llame al 5670-6169 Owner's Guide 4870 Series Index Important Safeguards ............ 2 Service Information ............... 4 Assembly ............................ 5-6 Use ..................................... 7-8 Thermal Cut Off ............... 4 & 8 Accessories ........................... 9 Clear Tubes .................... 10-11 Brush Roll ............................ 12 Brush Roll Belt ................ 12-13 Dust Bag ........................ 13-14 Filters ............................. 14-15 HEPA Filter .......................... 15 Light Bulb ............................ 15 Problem Solving .................. 16 Customer Order Form ......... 17 Warranty .............................. 19 Fill in and Retain: We suggest you record the model, type and serial numbers below, they are located on the silver rating plate on your cleaner, and attach the receipt to the owner' guide as proof of purchase. For prompt and complete service information, always refer to these numbers when inquiring about service. Model & Type__________________________________ Serial No. _____________________________________ www.eureka.com IMPORTANT SAFEGUARDS When using an electrical appliance, basic precautions should always be followed, including the following: READ ALL INSTRUCTIONS BEFORE USING THIS VACUUM CLEANER. WARNING To reduce the risk of fire, electric shock, or injury: · Do not use outdoors or on wet surfaces. · Do not leave vacuum cleaner when plugged in. Turn off the switch and unplug the electrical cord when not in use and before servicing. · Do not allow to be used as a toy. Close attention is necessary when used by or near children. · Use only as described in this manual. Use only manufacturer's recommended attachments. · Do not use with damaged cord or plug. If vacuum cleaner is not working as it should, has been dropped, damaged, left outdoors, or dropped into water, return it to a service center before using. · Do not pull or carry by cord, use cord as a handle, close a door on cord, or pull cord around sharp edges or corners. Do not run vacuum cleaner over cord. Keep cord away from heated surfaces. · Do not use extension cords or outlets with inadequate current carrying capacity. · Turn off all controls before unplugging. · Do not unplug by pulling on cord. To unplug, grasp the plug, not the cord. · Do not handle plug or vacuum cleaner with wet hands. · Do not put any object into openings. Do not use with any opening blocked; keep free of dust, lint, hair, and anything that may reduce airflow. · This vacuum cleaner creates suction and contains a revolving brush roll. Keep hair, loose clothing, fingers, and all parts of body away from openings and moving parts. · Do not place cleaner on furniture or stairs as the brush roll may cause damage. Place cleaner on floor with the handle in storage position while using attachments. · Do not pick up anything that is burning or smoking, such as cigarettes, matches, or hot ashes. · Do not use without dust bag in place. · Belt pulleys can become hot during normal use. To prevent burns, avoid touching the belt pulley when servicing the drive belt. · Use extra care when cleaning on stairs. · Do not use to pick up flammable or combustible liquids such as gasoline, or use in areas where they may be present. · Store your cleaner indoors in a cool, dry area. · Keep your work area well lighted. · Unplug electrical appliances before vacuuming them. SAVE THESE INSTRUCTIONS 2 CONSEILS DE SÉCURITÉ Lors de l'utilisation d'un appareil électrique, quelques précautions élémentaires doivent être observées, incluant les suivantes: LISEZ TOUTES LES INSTRUCTIONS AVANT D'UTILISER VOTRE ASPIRATEUR. AVERTISSEMENT Pour réduire le risque de feu, de choc électrique, ou de blessure: · Ne pas utiliser à l'extérieur ou sur des surfaces mouillées. · Fermez le commutateur et débranchez l'appareil lorsque vous ne l'utilisez pas ou avant le nettoyage ou l'entretien. · Ne permettez pas qu'il soit utilisé comme jouet. Une attention particulière est nécessaire lorsque utilisé par ou prés d'un enfant. · Suivez les recommandations d'utilisation de ce manuel. Utilisez uniquement les accessoires recommandés par le fabriquant. · Ne pas utiliser si le cordon ou la fiche sont endommagés. Si l'aspirateur ne fonctionne pas comme il le devrait, s'il a été échappé, s'il est endommagé, s'il a été laissé à l'extérieur ou échappé dans l'eau, retournez-le à un centre de service avant d'utiliser. · Ne pas le tirer ou le transporter par le cordon, ne pas utiliser le cordon en guise de poignée. Ne pas fermer une porte sur le cordon ou tirer le cordon sur des coins ou bordures pointus. Ne pas circuler sur le cordon avec l'aspirateur. Tenir le cordon à distance des surfaces chauffantes. · Ne pas utiliser des rallonges ou des prises qui n'ont pas de capacité suffisante pour transporter le courant. · Fermer tous les contrôles avant de débrancher. · Ne pas débrancher en tirant sur le cordon. Pour débrancher, tenez la fiche et non le cordon. · Ne pas manipuler la fiche ou l'aspirateur avec les mains mouillées. · Ne pas rien insérer dans les ouvertures. Ne pas utiliser si des ouvertures sont bloquées; assurez-vous qu'elles soient dégagées de poussière, mousse, cheveux ou toute autre chose qui pourrait réduire le passage de l'air. · Cet aspirateur créé de la succion et contient un rouleau-brosse tournant. Tenir les parties mobiles et les ouvertures loin des cheveux, du linge, des doigts et de toute partie du corps. · Ne pas mettre l'aspirateur sur les meubles ou sur les escaliers car le rouleau-brosse peut faire des dommages. Placer l'aspirateur sur le plancher avec le manche en entreposage position temps que les accessoires sont en usage. · Ne pas ramasser des objets qui brûlent ou fument comme les cigarettes, allumettes ou cendres chaudes. · N'utilisez pas sans le sac de poussière en place. · Les poulies du courroie peuvent devenir chaudes pendant l'utilisation normale. Pour prévenir des brûlures, évitez de touché la poulie du courroie lorsque vous réparez la courroie. · Portez une attention particulière lorsque vous nettoyez les escaliers. · Ne pas utiliser pour ramasser des liquides inflammables ou combustibles comme de l'essence: Ne pas utiliser dans les endroits où ces liquides pourraient être présents. · Entreposez votre aspirateur à l'intérieur dans un endroit propre et sec. · Maintenez un bon éclairage à l'endroit où vous travaillez. · Débrancher les appareils électrique avant de les balayer. CONSERVEZ CES INSTRUCTIONS 3 To reduce the risk of electric shock, this appliance has a polarized plug (one blade wider than the other). This plug will fit in a polarized outlet only one way. If the plug does not fit fully in the outlet, reverse the plug. If it still does not fit, contact a qualified electrician to install the proper outlet. Do not change the plug in any way. Afin de réduire le risque de choc électrique, cet appareil est muni d'une fiche polarisée (une des lames est plus large). Cette fiche ne peut être insérée dans une prise polarisée que d'une seule façon. Si la fiche ne peut être insérée dans la prise, retourner la fiche. Si la fiche ne peut toujours pas être insérée dans la prise, faire installer une prise adéquate par un électricien qualifié. Ne pas modifier la fiche. GENERAL INFORMATION The cleaner is designed to pick up dirt and dust particles. Avoid picking up hard or sharp objects with the cleaner to prevent bag tears and hose clogs with subsequent motor damage. Service Information The instructions in this booklet serve as a guide to routine maintenance. For additional service information telephone our toll free number for the nearest Eureka Authorized Warranty Station. You should know the model, type and serial numbers when you call: USA: 1-800-282-2886 Mexico: 5670-6169 Canada: 1-800-282-2886 If you prefer, you can write to The Eureka Company, Service Division, 807 N. Main Street, Bloomington, Illinois 61701, USA. In Canada write to The Eureka Company, 866 Langs Drive, Cambridge, Ontario N3H 2N7. Refer to The Eureka Limited Warranty for complete service information. DO NOT OIL the motor or the brush roll at any time. The bearings are permanently lubricated and sealed. Thermal Cut Off This vacuum cleaner has a special thermostat that protects the cleaner in case of motor overheating. If the cleaner suddenly shuts off, push the rocker switch to off (O) and unplug the cleaner. Check the cleaner for a possible source of overheating such as a full bag, a blocked hose or clogged filter. If these conditions are found, fix them and wait at least 30 minutes before attempting to use the cleaner. After the 30 minute period, plug the cleaner back in and turn on the switch. If the cleaner still does not run, then take it to a Eureka Authorized Service Center for repair. 4 HOW TO ASSEMBLE CAUTION: Assemble the cleaner before using. CAUTION: Moving parts. Make sure on/off switch is in off (0) position before plugging in. NOTE: Features may vary by model yet all parts assemble the same. Step A Attach Handle CAUTION: Do not catch cord under handle. Step B Store Hose and Accessories Handle Grooves Hose Retainer Upholstery Nozzle 3 Locations for Screws Crevice Tool Dusting Brush 1 2 3 Nozzle Nozzle Retainer 1. From rear of cleaner, align handle with grooves and slide onto cleaner. If necessary, use thumb and finger pressure to slide handle into position. 2. Attach handle with three 1 inch screws in the assembly packet. Use either a flat or Phillips® head screwdriver. 3. To store hose. Remove paper holding hose to unit. Lay hose over hose retainer and place nozzle on nozzle retainer. 4. Store tools, crevice tool, dusting brush and upholstery nozzle where indicated above. 5 Step C Check Disposable Dust Bag 5. Remove front cover. Lift bag cover latch up and pull bag cover away from unit. Step D Store Electrical Cord Bag Cover Latch 8 Cord Retainer 9 Cord Hook 6. Check to be sure the paper bag collar is secure with the bag adapter inside the paper bag collar. NOTE: Bag cover will not shut if paper bag is not properly installed. 9 Cord Hook Bag Adapter Paper Bag Collar 8. You will find your cord retainer on the handle above the upper cord hook. Firmly push the electrical cord down into the cord retainer before using the vacuum. This will place the cord out of the way while you are vacuuming. Remove cord from retainer when ready to store vacuum or when using hose and attachments. Next wind the cord around the two cord hooks on the back of cleaner. The upper cord hook turns to release the cord. Turn the hook up to store the cord. Secure the plug to the cord to prevent unwinding. 9. 7. Replace front bag cover. NOTE: See pages 13 & 14 for complete bag installation instructions. 10. 6 HOW TO USE 1. Cord Retainer. To use, push electrical cord down into cord retainer. 2. ON/OFF Switch. International symbol I means On, International symbol O means Off. 3. Hose/Floor Selector. Turn to select hose for above floor cleaning or floor for floor surface cleaning. If cleaning hard floor surface also adjust the cleaner height setting to hard floor. 4. Cam Latch. To release clear tubes. 1 5 3 2 4 6 5. Dirt Alert Indicator (on some models). The dirt alert sensor uses infrared technology to indicate whether or not floors are clean. When debris breaks the light beam, the red light comes on indicating additional cleaning is needed in this area. If there is no break in the light beam, the floor is clean and no light will come on. When using your new vacuum you may be cleaning deep down dirt missed by your old vacuum causing the light to stay red longer. With frequent cleaning, after the first few times you use your Eureka vacuum, the red light should go on less. To check if the dirt alert sensor is working properly: A. While the red light is on, tip the vacuum backwards on rear wheels, lifting the brush roll off the carpet a couple of inches. B. After a few seconds the red light should turn off. 6. Bag Change Indicator (on some models). Some models feature a bag change indicator to remind you to change the bag. When it is time to change the bag, the bag change indicator will illuminate. Certain types of fine particles like powder, plaster dust, or fine road dust can restrict airflow very quickly. The fine particles will decrease performance even before the bag appears to be full. C ...