User manual HAIER HD306

Dehumidifier Edition:2006/1/13 CAUTION READ THIS MANUAL CAREFULLY TO DIAGNOSE TROUBLE CORRECTLY BEFORE OFFERING SERVICE SERVICE MANUAL Dehumidifier MODEL:HD306,HD456,HD656 HD456E,HD656E THIS MANUAL IS USED BY QUALIFIED APPLIANCE TECHNICIANS ONLY HAIER DOES NOT ASSUME ANY RESPONSIBILITY FOR PROPERTY DAMAGE OR PERSONAL INJURY DAMAGE OR PERSONAL INJURY FOR IMPROPER SERVICE PROCEDURES DONE BY ONE UNQUALIFIED PERSON. REVISION 0 Dehumidifier Edition:2006/1/13 Model:HD306,HD456,HD656 Model:HD456E,HD656E 1.Two Fan Speeds 2.Easy To Control 3.Easy To Empty 4.Easy Clean Air Filter 5.Easy to move 6.Automatic Humidistat Control 7.Automatic Shut off/Indicator Light M a i n Specification MODEL:HD306,HD456,HD656,HD456E,HD656E Capacity(Pints/24hrs) 30/45/65/45/65 Efficiency(Liter/kwh) 1.2/1.5/1.6/1.5/1.6 Air flow Rate(CFM)-High/low 150,140/150,140/145,130/150,140/145,130 Watts(W) 480/550/650/550/650 1 Dehumidifier Edition:2006/1/13 Safety Information General Information This Service Manual describes the operation,disassembly,troubleshooting,and repair of Haier Room Air Conditioners,etc. It is intended for use by authorized servicers who troubleshoot and repair these units. NOTE:It is assumed that users of this manual are familiar with the use of tools and equipment used to troubleshoot and repair electrical,mechanical,and refrigeration systems;and understand the terminology used to describe and discuss them. Haier urges you read and follow all safety precautions and warnings contained in this manual. Failure to comply with safety information may result in severe personal injury or death. Related Publications This is a base service manual,covering a range of similar models.It is intended to be used in conjunction with the Parts Manual and Technical Sheet covering specific model being serviced. General Precautions and Warnings WARNING To avoid risk of personal injury or death due to electrical shock,disconnect electrical power to unit before attempting to service the unit. WARNING To avoid risk of personal injury or death due to electrical shock,DO NOT,under any circumstances,alter the grounding plug .Dihumidifier must be grounded at all times.Do not remove warning tag from power cord.If a two-prong (non-grounding) wall receptacle is encountered,contact a qualified electrician and have the receptacle replaced with a properly grounder wall receptacle in accordance with the National Electrical Code. WARNING To avoid risk of personal injury or death due to electrical shock,grounding wires and wires colored like grounding wires are NOT to be used as current carrying conductors.The standard accepted color coding for ground wires is green or green with a yellow stripe.Electrical components such as the compressor and fan motor are grounded through an individual wire attached to the electrical component and to another part of the dihumidifier.Grounding wires should not to be removed from individual components while servicing,unless the component is to be removed and replaced.It is extremely important to replace all removed grounding wires before completing service. WARNING To avoid risk of heat exposure,which may cause death or severe illness,Dihumidifier must be monitored when malfunctions or shuts down. 2 Dehumidifier Edition:2006/1/13 CONTENTS 1.SPECIFICATION...............................................................................4 2.OPERATION.....................................................................................6 3.TROUBLE SHOOTING....................................................................11 4.ELECTRICAL CONTROLL...............................................................13 5.CIRCUIT AND WIRING DIAGRAM.................................................. 16 3 Dehumidifier Edition:2006/1/13 4 Dehumidifier Edition:2006/1/13 HD306 HD456 HD656 HD456E HD656E Performance 30 45 65 45 65 Capacity - Pints/24hrs 1.2 1.5 1.6 1.5 1.6 Efficiency - Liter/kwh 150/140 150/140 145/130 150/140 145/130 Airflow Rate (CFM) - High / Low Noise Level (db) - High / Low 50/45 dB A£© 53/50 dB A£© 55/52 dB A£© 53/50 dB A£© 55/52 dB A£© £¨ £¨ £¨ £¨ £¨ 25 pt 25pt 25pt 25pt 25pt Bucket Capacity Rotary Rotary Rotary Rotary Rotary Compressor Type Refrigerant Type/Charge amount R22/4.41 R22/9.88 R22/10.58 R22/9.88 R22/10.58 (Oz) Electrical 115 - 60 115 - 60 115 ­ 60 115 - 60 115 ­ 60 Voltage - Frequency (Hz) 5.8 6 6.6 6 6.6 Amps Watts Circuit Size (Amps) Plug Capacity Plug Type / NEMA# Power Cord Length Dimensions and Installation Unit Dimensions (In) Height Width Depth Weight (lbs) Net / Ship Shipping Carton Dimensions (In) Height Width Depth Container Loading (40' HQ) 480W 5.8 125/15 A / 5-15P 6' 550W 6 125/15 A / 5-15P 6' 650W 6.6 125/15 A / 5-15P 6' 550W 6 125/15 A / 5-15P 6' 650W 6.6 125/15 A / 5-15P 6' 22 1/4 14 3/8 13 3/8 22 1/4 14 3/8 13 3/8 22 1/4 14 3/8 13 3/8 22 1/4 14 3/8 13 3/8 22 1/4 14 3/8 13 3/8 37.5/41.9 40.8/45.2 43.2/47.6 40.8/45.2 43.2/47.6 25 3/16 16 5/32 15 11/32 25 3/16 16 5/32 15 11/32 25 3/16 16 5/32 15 11/32 25 3/16 16 5/32 15 11/32 25 3/16 16 5/32 15 11/32 696 696 696 696 696 5 Dehumidifier Edition:2006/1/13 6 Dehumidifier Edition:2006/1/13 Model:HD456E,HD656E 7 Dehumidifier Model: HD306,:HD456,HD656 Edition:2006/1/13 8 Edition:2006/1/13 9 Dehumidifier Edition:2006/1/13 10 Dehumidifier Edition:2006/1/13 TROUBLE SHOOTING 11 Dehumidifier Edition:2006/1/13 12 CIRCUIT AND WIRING DIAGRAM 13 Dehumidifier Edition:2006/1/13 Mode :HD306,HD456,HD656 14 Edition:2006/1/13 Mode l:HD456E,HD656E 15 Dehumidifier Edition:2006/1/13 Temperat re Humidity LV-PCB PIH R C L-H V W£« G WATER FULL SWITCH HV-PC L-LINE G HUMIDITY ROOM TEMP PIPE TEMP HD456E,HD656E HIGH FAN LOW FAN COMPRESSORN-LINE 16 Dehumidifier Edition:2006/1/13