ThinkPad X60 Tablet Hardware Maintenance Manual ® November 2006 This manual supports: ThinkPad X60 Tablet (MT 6363, 6364, 6365, 6366, 6367, and 6368) ThinkPad X60 Tablet Hardware Maintenance Manual ® Note Before using this information and the product it supports, be sure to read the general information under "Notices" on page 122. First Edition (November 2006) © Copyright Lenovo 2006. All rights reserved. U.S. GOVERNMENT USERS ­ RESTRICTED RIGHTS: Our products and/or services are provided with RESTRICTED RIGHTS. Use, duplication or disclosure by the Government is subject to the GSA ADP Schedule contract with Lenovo Group Limited, if any, or the standard terms of this commercial license, or if the agency is unable to accept this Program under these terms, then we provide this Program under the provisions set forth in Commercial Computer Software­Restricted Rights at FAR 52.227-19, when applicable, or under Rights in Data-General, FAR 52.227.14 (Alternate III). Contents About this manual . . . . . . . . . . 1 Introduction . . . . . . . . . . . . . 3 Important service information . . . . . . . . 3 Strategy for replacing FRUs . . . . . . . . . 3 Strategy for replacing a hard disk drive . . . . 4 Important notice for replacing a system board . . 4 How to use error messages . . . . . . . . 4 Strategy for replacing FRUs for CTO, CMV, and GAV 4 Product definition . . . . . . . . . . . 4 FRU identification for CTO, CMV, and GAV products . . . . . . . . . . . . . . . 5 Important information about replacing RoHS compliant FRUs . . . . . . . . . . . . . 6 Diskette compatibility matrix . . . . . . . . . 7 Safety notices: multilingual translations . . . . . 7 Safety information . . . . . . . . . . . . 13 General safety . . . . . . . . . . . . 13 Electrical safety . . . . . . . . . . . . 13 Safety inspection guide . . . . . . . . . 15 Handling devices that are sensitive to electrostatic discharge . . . . . . . . . . 16 Grounding requirements . . . . . . . . . 16 Laser compliance statement . . . . . . . . . 17 FRU replacement notices . . . . . . . . . . 50 Screw notices . . . . . . . . . . . . . 50 Retaining serial numbers . . . . . . . . . 50 Removing and replacing a FRU . . . . . . . . 53 1010 Battery pack . . . . . . . . . . . 54 1020 Hard disk drive slot cover, hard disk drive rubber rails, and hard disk drive . . . . . . 55 1030 DIMM slot cover and DIMM . . . . . . 57 1040 Hinge caps . . . . . . . . . . . . 59 1050 Keyboard . . . . . . . . . . . . 61 1060 Backup battery . . . . . . . . . . 64 1070 LCD extend board . . . . . . . . . 65 1080 Keyboard bezel . . . . . . . . . . 66 1090 Modem daughter card (MDC-1.5) . . . . 67 1100 PCI Express Mini Card for wireless LAN . . 69 1110 PCI Express Mini Card for wireless WAN . 70 1120 Bluetooth daughter card (BDC-2) . . . . 71 1130 DC-in connector and modem cable . . . . 72 1140 Speaker assembly . . . . . . . . . 73 1150 LCD assembly . . . . . . . . . . . 74 1160 Pen switch assembly, Bluetooth cable, and base cover . . . . . . . . . . . . . . 77 1170 HDD connector sub card . . . . . . . 80 1180 Fan assembly . . . . . . . . . . . 81 1190 System board, PC Card/ExpressCard slots assembly . . . . . . . . . . . . . . 82 2010 LCD front bezel . . . . . . . . . . 85 2020 Center latch . . . . . . . . . . . 86 2030 Fingerprint reader . . . . . . . . . 87 2040 Inverter card . . . . . . . . . . . 88 2050 Micro processor board . . . . . . . . 89 2060 Hinge and microphone cable . . . . . . 90 2070 Micro processor board/inverter card FFC (flexible flat cable), LCD panel with digitizer, and LCD cable . . . . . . . . . . . . . . 92 2080 Wireless antenna cables and LCD rear cover 94 Locations . . . . . . . . . . . . . . . 96 Front view. . . . . . . . . . . . . . 96 Rear view . . . . . . . . . . . . . . 97 Rear view (tablet mode) . . . . . . . . . 97 Bottom view . . . . . . . . . . . . . 98 Rear view (ThinkPad X6 Tablet UltraBase) . . . 99 Bottom view (ThinkPad X6 Tablet UltraBase) . . 99 Parts list . . . . . . . . . . . . . . . 100 Overall . . . . . . . . . . . . . . 100 LCD FRUs . . . . . . . . . . . . . 109 Keyboard . . . . . . . . . . . . . . 116 Recovery CDs . . . . . . . . . . . . 117 Miscellaneous parts . . . . . . . . . . 118 AC adapters . . . . . . . . . . . . . 119 Optional FRUs . . . . . . . . . . . . 119 Common parts list. . . . . . . . . . . 120 Notices . . . . . . . . . . . . . . . 122 Trademarks . . . . . . . . . . . . . . 123 General descriptions . . . . . . . . . 19 Read this first . . . . . . . . . . . . What to do first . . . . . . . . . . . Related service information . . . . . . . . Service Web site . . . . . . . . . . . Restoring the factory contents by using Product Recovery CDs . . . . . . . . . . . Passwords . . . . . . . . . . . . . Power management . . . . . . . . . Checkout guide . . . . . . . . . . . . Testing the computer . . . . . . . . . Detecting system information with PC-Doctor . Power system checkout . . . . . . . . . . . . . . . . . . . 19 19 21 21 21 22 24 27 27 29 30 ThinkPad X60 Tablet . . . . . . . . . 33 Product overview . . . Specifications . . . . Status indicators . . . FRU tests . . . . . Fn key combinations . Symptom-to-FRU index . Numeric error codes . Error messages . . . Beep symptoms . . . No-beep symptoms . . LCD-related symptoms Intermittent problems . Undetermined problems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34 34 36 38 40 42 42 46 47 47 48 49 49 © Copyright Lenovo 2006 iii iv MT 6363, 6364, 6365, 6366, 6367, and 6368 About this manual This manual contains service and reference information for ThinkPad® X60 Tablet (MT 6363, 6364, 6365, 6366, 6367, and 6368) products. Use this manual along with the advanced diagnostic tests to troubleshoot problems. The manual is divided into sections as follows: v The common sections provide general information, guidelines, and safety information required in servicing computers. v The product-specific section includes service, reference, and product-specific parts information. Important This manual is intended for trained service personnel who are familiar with ThinkPad products. Use this manual along with the advanced diagnostic tests to troubleshoot problems effectively. Before servicing a ThinkPad product, be sure to review the safety information under "Safety notices: multilingual translations" on page 7, "Safety information" on page 13, and "Laser compliance statement" on page 17. © Copyright Lenovo 2006 1 2 MT 6363, 6364, 6365, 6366, 6367, and 6368 Introduction Important service information Important BIOS and device driver fixes are customer-installable. The BIOS and device drivers are posted on the customer support site http://www.lenovo.com/ support Advise customers to contact the Customer Support Center at 800-426-7378 if they need assistance in obtaining or installing any software fixes, drivers, and BIOS downloads. Customers in Canada should call the Customer Support Center at 800-565-3344 for assistance or download information. Strategy for replacing FRUs Before replacing parts Make sure that all software fixes, drivers, and BIOS downloads are installed before replacing any FRUs listed in this manual. To download software fixes, drivers, and BIOS, do as follows: 1. Go to http://www.lenovo.com/support 2. Enter the product number of the computer or press Auto-detect button on the screen. 3. Select Downloads and drivers. 4. Follow the directions on the screen and install the necessary software. Use the following strategy to prevent unnecessary expense for replacing and servicing FRUs: v If you are instructed to replace a FRU but the replacement does not correct the problem, reinstall the original FRU before you continue. v Some computers have both a processor board and a system board. If you are instructed to replace either the processor board or the system board, and replacing one of them does not correct the problem, reinstall that board, and then replace the other one. v If an adapter or a device consists of more than one FRU, any of the FRUs may be the cause of the error. Before replacing the adapter or device, remove the FRUs, one by one, to see if the symptoms change. Replace only the FRU that changed the symptoms. Attention: The setup configuration on the computer you are servicing may have been customized. Running Automatic Configuration may alter the settings. Note the current configuration settings (using the View Configuration option); then, when service has been completed, verify that those settings remain in effect. © Copyright Lenovo 2006 3 Important service information Strategy for replacing a hard disk drive Always try to run a low-level format before replacing a hard disk drive. Attention: The drive startup sequence in the computer you are servicing may have been changed. Be extremely careful during write operations such as copying, saving, or formatting. If you select an incorrect drive, data or programs can be overwritten. Important notice for replacing a system board Some components mounted on a system board are very sensitive. Improper handling of a system board can cause damage to those components, and may cause a system malfunction. Attention: When handling a system board: v Do not drop a system board or apply any excessive force to it. v Avoid rough handling of any kind. v Avoid bending a system board and hard pushing to prevent cracking at each BGA (Ball Grid Array) chipset. How to use error messages Use the error codes displayed on the screen to diagnose failures. If more than one error code is displayed, begin the diagnosis with the first error code. Whatever causes the first error code may also cause false error codes. If no error code is displayed, see whether the error symptom is listed in the Symptom-to-FRU Index for the computer you are servicing. Strategy for replacing FRUs for CTO, CMV, and GAV Product definition Dynamic Configure To Order (CTO) This provides the ability for a customer to configure an IBM® or a Lenovo solution from an eSite, and have this configuration sent to fulfillment, where it is built and shipped directly to the customer. The machine label, PC Entitlement Warehouse (PEW), eSupport, and the HMM will load these products as the 4-digit MT and 3-digit model, where model = "CTO" (Example: 1829-CTO). Custom Model Variant (CMV) This is a unique configuration that has been negotiated between IBM or Lenovo and the customer. A unique 4-digit MT and 3-digit model is provided to the customer to place orders (Example: 1829-W15). A CMV is a special bid offering. Therefore, it is NOT generally announced. v The MTM portion of the machine label is the 4-digit MT and 3-digit model, where model = "CTO" (Example: 1829-CTO). The PRODUCT ID portion of the machine label is the 4-digit MT and 3-digit CMV model (Example: 1829-W15). v The PEW record is the 4-digit MT and 3-digit model, where model = "CTO" (Example: 1829-CTO). v eSupport will show both the CTO and CMV machine type models (Example: 1829-CTO and 1829-W15 will be found on the eSupport site.) v The HMM will have the 4-digit MT and 3-digit CTO model only (Example: 1829-CTO). Again, CMVs are custom models and are not found in the HMM. 4 MT 6363, 6364, 6365, 6366, 6367, and 6368 Important service information General Announce Variant (GAV) This is a standard model (fixed configuration). GAVs are announced and offered to all customers. The MTM portion of the machine label is a 4-digit MT and 3-digit model, where model = a "fixed part number", not "CTO" (Example: 1829-F1U). Also, PEW, eSupport, and the HMM will list these products under the same fixed model number. FRU identification for CTO, CMV, and GAV products There are three information resources to identify which FRUs are used to support CTO, CMV, and GAV products. These sources are PEW, eSupport, and the HMM. Using PEW v PEW is the primary source for identifying FRU part numbers and FRU descriptions for the key commodities for CTO, CMV and GAV products at a MT - serial number level. An example of key commodities are hard disk drives, system boards, microprocessors, Liquid Crystal Displays (LCDs), and memory. v Remember, All CTO and CMV products are loaded in PEW under the 4-digit MT and 3-digit model, where model = "CTO" (Example: 1829-CTO). GAVs are loaded in PEW under the 4-digit MT and 3-digit model, where model = a "fixed part number", not "CTO" (Example: 1829-F1U). v PEW can be accessed at the following Web site: http://w3-3.ibm.com/pc/entitle Customers can also access PEW via http://www-307.ibm.com/pc/support/site.wss/product.do?template=/ warranty/warranty.vm&sitestyle=lenovo Click on MACHINE LOOKUP, followed by WARRANTY INFORMATION. Input the MT and the Serial number and the list of key commodities will be returned in the PEW record under COMPONENT INFORMA ...