Pool FROG In GROUND MINERAL SYSTEM FOR POOLS Patented Mineral Pool Sanitizer ROG OL F VOIR PO THE L RESER ED RA AC MINE BE REPL THS MUST SIX MON OOL Y P EVER ER ONE VER FT HE OR A N WHIC . O R SEAS SHORTE IS ® Instruction Manual Customer Service 800-222-0169 TABLE OF CONTENTS POOL FROG Introduction Swimming Pool Tips Start-up and Operation Replacing POOL FROG Mineral Reservoir Replacing FROG BAM ® ® ® 3 4 5-6 7 8 Replacing POOL FROG Bac Pac Troubleshooting Parts List Replacing Control Dial O-Rings Replacing Cap O-Ring and Knob Winterizing In-line Installation Off-line Installation For Proper Performance Warranty ® 9 10 11 12 12 13 14 15-16 17 18 POOL FROG ® Welcome to easier pool care courtesy of POOL FROG®. With POOL FROG®, your pool water will look and feel better without a lot of work or a lot of chlorine. This system controls bacteria using a combination of minerals and reduced chlorine levels­up to 50%* less. There are 4 parts to the POOL FROG® System: The In Ground POOL FROG® Cycler, the POOL FROG® Mineral Reservoir, FROG BAM 90-day Algae Preventative and the POOL FROG® Bac Pac. ® Part 1 POOL FROG® Cycler The water treatment center that controls the flow of water to each part of the POOL FROG® System. Part 2 POOL FROG® Mineral Reservoir Holds the minerals and fits inside the POOL FROG® Cycler. LL OUT PU D READ AN Min FROG POOL h the ults, the used wit st res uld be For be oir sho Reserv Bac Pac. e chlorin ® eral the Bac remove Simply tabs on the the d colore insert into oir. erv Pac and the Res of center size your dial for and Set the e pump day siz e per pool, a -run tim intain e pump ust to ma chlorin and adj 1 ppm ter l). .5 to the cen low manua (see else into a Bac Pac level thing but pool put any Reservoir to the l Do not damage Minera of the hnology or Tec result. King could from rce ment uip te sou or eq alterna floater or r, has an pool orinato ntrol Pac If the (a chl Co the orine Flow ter of g), a of chl the cen good feedin ure hand ced in ls. be pla oir to ens minera must l Reserv ugh the Minera thro l Pac, ter flow wa Contro a Flow -0169 need 00-222 duct. If you call 1-8 pro please you use the e befor to copy BAM come For In Ground Pools up to 40,000 gallons. E ERING FOR MO MET Setting Chart in Manual DEL e Se P RE CIS 3 4 5 6 54 0 0 Pac Removal Maximum THE POOL FROG MINERAL RESERVOIR MUST BE REPLACED EVERY SIX MONTHS OR AFTER ONE POOL SEASON WHICHEVER IS SHORTER. ® 7 1 2 Part 3 FROG BAM® Use with the POOL FROG® System for an Algae-Protection Guarantee. (POOL FROG® Mineral Reservoir sold inside POOL FROG® Cycler and separately for replacements. POOL FROG® Bac Pac and FROG BAM® sold separately.) *Compared to the minimum EPA recommended chlorine level of 1.0 ppm for a stablized swimming pool. 8 Part 4 POOL FROG® Bac Pac Pre-filled with chlorine tablets and fits inside the POOL FROG® Mineral Reservoir. Swimming Pool Tips Start-up and Yearly Maintenance 1. 3. · Make sure the pool has adequate circulation. The pool water must completely circulate through the pump and filter at least 1 to 2 times per day. This usually requires 8 to 12 hours. Check with your dealer for the proper circulation time for your pool. · If your fill water is high in metals, use a sequestering agent or metal out product at start-up only before using the POOL FROG® Mineral Reservoir. See your local dealer for details on using these products and always follow manufacturers directions carefully. 4. · After your pool is up and running smoothly, continue to test your water for pH, total alkalinity and chlorine and maintain its balance by adding any necessary adjustment products (see your dealer for details). 2. · Before beginning with any pool care program, you must first balance your pool water. Take a water sample to your local pool professional or use a complete test kit that will test for the following important elements. 5. Water Balance Guidelines pH: Total Alkalinity: Calcium Hardness: Total Dissolved Solids: Stabilizer: Free Chlorine: 7.2 -- 7.8 60 -- 120 ppm 150 -- 400 <1500 20 -- 80 ppm 0.5 -- 1.0 ppm · Check the pool's filter gauge often and periodically clean filter per the manufacturer's directions. A dirty filter will slow the flow of water which could hamper proper circulation. Start-up and Operation · Add a stabilizer or conditioner to 1. the pool at the beginning of the season if the stabilizer level is below 20 ppm. This will prevent chlorine burn off. Follow manufacturer's directions carefully. 4. · Replace cap and run POOL FROG® Cycler, with POOL FROG® Mineral Reservoir inserted, for 10 minutes on Setting Maximum. 2. · Shock the pool with chlorine to rid the water of all contaminants before beginning with POOL FROG®. Follow manufacturer's directions carefully. · THIS STEP IS VERY IMPORTANT 5. · For an Algae Protection Guarantee insert FROG BAM® into POOL FROG® Mineral Reservoir in POOL FROG® Cycler. (Follow directions on page 8.) TO START-UP. USE CHLORINE SHOCK ONLY. · Do not add shock in or near the skimmer or into the POOL FROG® Cycler as it could damage equipment, risk potential explosion or discolor your pool surface. 6. · When chlorine reading is down to 1.0 ppm, which may take a few days, insert POOL FROG® Bac Pac. (Follow directions on page 9.) 3. · Install a POOL FROG Mineral ® Reservoir into the POOL FROG® Cycler. (Follow directions on page 7.) REPLACE THE POOL FROG® MINERAL RESERVOIR EVERY 6 MONTHS OR AFTER ONE POOL SEASON WHICHEVER IS SHORTER. Start-up and Operation 7. · Set control dial by matching up the parameters of your pool on the chart below. THIS IS A STARTING POINT ONLY and may need to be adjusted to fit your individual pool needs. See #8 for directions. IMPORTANT: Pump run times less than 8 hours could result in under chlorination due to inadequate flow through the System. 8 Hour Pump Run Time 3/4 hp 3.5 4 4.5 NR NR NR NR NR PUMP SIZE 1 hp 1 1/2 hp 3 3.5 4 4.5 NR NR NR NR 2.5 3 3.5 4 4.5 5.5 6.5 NR 2 hp In Ground POOL SIZE Gallons 7,000 9,000 12,000 18,000 25,000 30,000 35,000 40,000 12 Hour Pump Run Time 3/4 hp 3 3.5 4 5 NR NR NR NR PUMP SIZE 1 hp 1 1/2 hp 2.5 3 3.5 4 5 5.5 6.5 NR 2 hp 24 Hour Pump Run Time 3/4 hp 1.5 2.5 3 3.5 4 4.5 5.5 6.5 1 hp PUMP SIZE 1 1/2 hp 2 hp 4 2.5 3 3.5 4 4.5 5.5 * 2.5 2.5 3 3.5 3.5 4.5 5.5 6.5 * 4 2.5 3 3.5 4 5 5.5 6.5 * * 3.5 4 2.5 3 3.5 4 5 5.5 * * 3.5 * * 3 3.5 1.5 2.5 3 3.5 4 4.5 * * * 2.5 3 3.5 2 2.5 3 3.5 4 * ­ Bypass installation recommended. NR ­ This pump size is not recommended for this size pool. RECOMMENDED FLOW RATE: 20-80 gpm Most common pool sizes Find your starting dial setting by matching up the parameters of your pool on the above chart. An In ground pool with approximately 18,000 gallons with a 1 horse pump running 12 hours a day would require a starting setting of 4. See example at right. 3/4 hp 3.5 4 4.5 NR NR NR NR NR 1 hp 3 3.5 4 4.5 NR NR NR NR 1 1/2 hp 2.5 3 3.5 4 4.5 5.5 6.5 NR 2 hp * 2.5 2.5 3 3.5 3.5 4.5 5.5 6.5 * * * Test Strips 8. · For the first week test the If using another means of chlorine support Pool and Spa Test Strips pool water daily for free chlorine to ensure correct dial setting. Continue to test weekly throughout the season. Follow steps 1-5 on page 5 then continue below. · After each testing, adjust the dial up by 1/2 increment if the free chlorine reading has dropped below 0.5 ppm or adjust down by 1/2 increment if the reading has risen above 1.0 ppm. Continue this process each day until the free chlorine reading stabilizes to at least 0.5 ppm. · Remember to adjust dial ONLY by 1/2 setting per day in 6. Maximum · Set dial to Maximum. Maintain a minimum chlorine reading of 0.5 ppm with a chlorine delivery device or hand feeding. order to prevent over chlorination which may bleach pool surfaces. 9. · Shock pool every two weeks or as needed to maintain water quality. Follow label directions on the shock treatment used. · Do not add shock in or near the skimmer or into the POOL FROG® Cycler as it could damage equipment, risk potential explosion or discolor your pool surface. 7. · Shock pool every two weeks or as needed to maintain water quality. Follow label directions on the shock treatment used. · Do not add shock in or near the skimmer or into the POOL FROG® Cycler as it could damage equipment, risk potential explosion or discolor your pool surface. Replacing a POOL FROG Mineral Reservoir ® (POOL FROG® Mineral Reservoirs MUST be Replaced Every Season) 1. IN GROUND SERIES 5400 (Order #01-12-5462) NOW FITS THE FOLLOWING CYCLERS: POOL FROG Series 5400 or 5600 Prevail Series 5790 4. 22906 05406 2 7 · Check the front of the box and back label of product to make sure you have the correct POOL FROG® Mineral Reservoir to fit your POOL FROG® Cycler. THE POOL FROG® MINERAL RESERVOIR MUST BE REPLACED EVERY 6 MONTHS OR AFTER ONE POOL SEASON WHICHEVER IS SHORTER Pac Removal · Turn off pump.Turn dial to Pac Removal. This reduces the flow of water into the unit when the cap is open. 2. Open the box and remove the POOL FROG® Mineral Reservoir. · IMPORTANT: Remove and read the 5. information card. Please note: Complete instructions for inserting a POOL FROG® Mineral Reservoir, FROG BAM® and POOL FROG® Bac Pac are included inside the POOL FROG® Mineral Reservoir box. · Use the cap tool included with POOL FROG® Cycler to loosen cap by hitting the handle with the flat of your hand counter clockwise. If using the POOL FROG® Bac Pac, stand back to avoid inhaling chlorine fumes. 3. CAUTION read carefully · USE ONLY the factory recommended replacement 6. SLOT IN POOL FROG MINERAL RESERVOIR · Find slot on side of POOL FROG® Mineral Reservoir, FROG BAM® and POOL FROG® Bac Pac. DO NOT USE any other pac or bulk chemical tablets in the POOL FROG® Cycler. Use of any other product could result in damage to pool equipment or surface, unsafe pool conditions, fire or explosion. Warranty will be void if the correct POOL FROG® Mineral Reservoir, FROG BAM® and POOL FROG® Bac Pac are not used. FIN INSIDE OF POOL FROG CYCLER POOL FROG® Mineral Reservoir and line up with fin inside the POOL FROG® Cycler. Lower POOL FROG® Mineral Reservoir into POOL FROG® Cycler until secure. 7 Replace FROG BAM for an Algae Protection Guarantee ® If you are not replacing FROG BAM®, proceed to Step 15. See FROG BAM® product labeling for complete directions for use (EPA Reg. No. 53735-9). For a preventive dose add: ® ·One FROG BAM for pools up to 15,000 gallons. ® ·Two FROG BAM for pools between 15,000 and 30,000 gallons. 7. · Remove cap from 11. FROG BAM® without removing seal. · Turn pump on for 90 minutes allowing FROG BAM® to circulate through pool. 90 DAY ALGAE PROTECTION 12. · To remove FROG BAM , Pac Removal ® turn pump off. Turn dial to Pac Removal. 9. · Replace cap by hand only. DO NOT OVER TIGHTEN. 10. · Turn control dial on POOL FROG® Cycler to Maximum. 1 2 Maximum P REC IS E RING FOR MO METE g Chart in Manual DEL Settin See 3 Pac Removal 8 90 DAY ALGAE PROTECTION 90 DAY ALGAE PROTECTION 8. · Insert upside down into center of POOL FROG® Mineral Reservoir pushing down firmly on key inside POOL FROG® Cycler to puncture seal on FROG BAM® bottle. 13. · Remove POOL FROG ® Cycler cap. · Lift FROG BAM up and ® 14. allow any water in the container to drain through the POOL FROG® Cycler before discarding in trash. NOTE: If water shows more than a hint of blue inside POOL FROG® Cycler, replace the POOL FROG® Cycler cap, turn dial to Maximum and run the pump for one minute. 14a. If pool size requires additional FROG BAM®, repeat steps 7-14. 14b. When water is clear in POOL FROG® Cycler, proceed to step 15. 4 5 6 54 0 0 7 8 Maximum Replacing POOL FROG Bac Pac ® 15. ·Colored caps · POOL FROG Bac Pac ® recommended to assure up to 50% reduction in chlorine use*. POOL FROG® Bac Pac sold separately. (EPA Reg. No. 53735-2) 19. · Line up the small leg of the *Compared to the minimum EPA recommended chlorine level of 1.0 ppm for a stabilized swimming pool. POOL FROG® Bac Pac with the small opening in the POOL FROG® Mineral Reservoir and the large leg with the large opening. Lower POOL FROG® Bac Pac into POOL FROG® Mineral Reservoir until secure. POOL FROG MINERAL RESERVOIR POOL FROG BAC PAC 16. · Avoid sparks, open flame or smoking when handling the POOL FROG® Bac Pac. 20. · Replace cap by hand only. DO NOT OVER TIGHTEN. 17. · To remove POOL FROG ® · DO NOT USE CAP TOOL TO TIGHTEN CAP. Use for removal only. Bac Pac colored caps, grab on to the lip of one cap with a pliers and pull up until cap releases. Repeat the process for the other cap. 21. 18. · Holding the POOL FROG® Bac Pac over the POOL FROG® Mineral Reservoir turn POOL FROG® Bac Pac over and shake slightly until chlorine ta ...