BOOK# 091-9C-HO-3 4-22-2002 INSTRUCTION MANUAL PUMP-PLUS HO HIGH OUTPUT AIR COMPRESSOR / BATTERY CHARGER MODEL #091-9C-HO NOTE : This charger is designed for vehicles with dual batteries and negative ground. INPUT :120 volt, 50/60 Hz OUTPUT: 13.25 VOLTS, 11 AMPERES 3 YEAR WARRANTY KUSSMAUL ELECTRONICS CO., INC. 170 CHERRY AVE., WEST SAYVILLE, N.Y. 11796 TEL: in NY 631-567-0314 TOLL FREE: 800-346-0857 FAX: 631-567-5826 INTRODUCTION The Pump Plus HO Automatic Battery Charger is a compact, completely automatic, dual channel battery charger designed for vehicles with a two battery system. The charger is ruggedized to withstand the shock and vibration encountered by vehicle mounted equipment. Battery Charger Features: · Independent charge controls for each battery · Automatic current limiting · Optional dual battery charge/condition indicator · Power "ON" LED indicator DESCRIPTION Independent Charge Controls The Pump Plus HO contains two independent charge controls, one for each battery. This allows each battery to be independently charged while maintaining battery isolation. Each battery is individually sensed, eliminating the need for sense wires. Each of the charge controls is completely automatic and stops charging the battery when it is fully charged. There is no trickle charge and therefore no danger of overcharging and water boil-off. Automatic Current Limiting When batteries are severely discharged, some battery chargers can be overloaded due to the high charging current required. The Pump Plus HO contains an automatic current limit. This circuit limits the output current to the rated 11 amperes when charging a deeply discharged battery or if the starter cranks the engine while starting. The current limiter thus eliminates the need for an ignition interlock circuit. SPECIFICATION Input: 120 volts A.C., 50/60 Hz., 3 amperes Input Fuse: 5 amperes, fast acting Pump Fuse: 15 amperes, slow blow Output Volts: 13.25 volts, nominal Output Current: 0 to 11 amperes, D.C., output determined by the state of charge of the batteries Remote Charge Indicator: Red Led indicates charging current Green Led indicates batteries are fully charged Weight: 12 lb. INSTALLATION RECORD & WARRANTY Date Installed Installed By Vehicle Identification Vehicle Owner WARRANTY All products of Kussmaul Electronics Company Inc. are warranted to be free of defects of material or workmanship. Liability is limited to repairing or replacing at our factory, without charge, any material or defects which become apparent in normal use within 3 years from the date the equipment was shipped. Kussmaul Electronics Company, Inc. shall have no liability for damages of any kind to associated equipment arising from the installation and /or use of the Kussmaul Electronics Company, Inc. products. The purchaser, by the acceptance of the equipment, assumes all liability for any damages which may result from its installation, use or misuse, by the purchaser, his or its employees others. ...