210 Sprinter Models Owner's Manual Including Limited Warranty Information WARNINGS & CAUTIONS WARNINGS AND CAUTIONS This manual contains WARNINGS against operating procedures which could result in an accident or bodily injury. The manual also contains CAUTIONS against procedures which could result in damage to your vehicle. If you do not read the entire manual you may miss important information. Observe all Warnings & Cautions. Doc No: 21906540-RSAD Rev: 00 Copyright © Hanmar Motor Corporation 2005 WARNINGS & CAUTIONS WARNINGS: SEAT BELTS: Only forward facing seats equipped with factory installed seat belts are to be occupied while the vehicle is in motion. All passengers must be seated in these seats only, with the seat belts fastened while the vehicle is in motion. TV: The flat screen TV should not be stored inside the Roadtrek in temperatures below -4°F, (-20°C) to reduce the chance of damage from the cold. The operating temperature of the monitor is recommended between 50°F and 104°F, (10°C and 40°C) with a humidity range of 10% to 80%, non condensing. If your vehicle is equipped with an optional flat screen TV, the TV must be off and in the stored position during travel. PROPANE: Propane tanks shall not be placed or stored inside your vehicle. Propane tanks are equipped with safety devices which relieve excessive pressure by discharging gas to the atmosphere. To reduce the danger of fire or explosion do not store gasoline or other flammable liquids inside your vehicle. Ensure you purchase propane from a reputable propane facility. Contaminated propane is a common cause of system failure. Do not refuel the propane tank to more than 80% of its capacity. The propane tank valve must be closed and ALL PILOT LIGHTS, APPLIANCES, AND THEIR IGNITERS, (see Operating Instructions) SHALL BE TURNED OFF during refueling of motor fuel tank and/or the propane tank. Only qualified personnel should refuel your propane tank. APPLIANCES: It is not safe to use cooking appliances for space heating purposes due to the danger of asphyxiation. The propane stove needs fresh air for its safe operation. Portable fuel burning equipment, including wood or charcoal grills and stoves, should not be used inside your vehicle. Use of this type of equipment inside your vehicle may cause fire or asphyxiation. PROPANE LEAK DETECTOR: Do not block air circulation in the area where the Propane Leak Detector is located. Battery disconnect switch must be in the "ON" position for the propane detector to function. CARBON MONOXIDE LEAK DETECTOR: Do not block air circulation in the area where the carbon monoxide leak detector is located. Battery disconnect switch must be in the "ON" position for the Carbon Monoxide Leak Detector to function. Doc No: 21906540-RSAD Rev: 00 Copyright© Hanmar Motor Corporation 2005 WARNINGS & CAUTIONS 110 VOLT ELECTRICAL SERVICING: Prior to servicing the 110 volt Galley GFCI & Audio/Video cabinet interior receptacles, unplug the output lead from the power inverter. EXTERIOR ACCESS DOORS: Ensure power cord and city water line are disconnected and in their stored positions before vehicle is put in motion. CAUTIONS: CLOVERLEAF DINING TABLE: Cloverleaf dining table is heavy, bend knees while lifting. EXTRA COUNTER SPACE: Make sure the stove is off and has cooled prior to lowering the stove cover. TV: When the vehicle is in motion it is recommended that the TV be "OFF" and in the stored position. The flat screen TV, (option TF) should not be stored inside the Roadtrek in temperatures below -4°F, (-20°C). The operating temperature of the monitor is recommended between 50°F & 104°F, (10°C ­ 40°C) with a humidity range of 10%-80%, non condensing. To remove the T/V, remove the four mounting bolts on the back of the T/V mounting bracket and remove the RCA cables, power supply cable and antenna cable. AUXILIARY BATTERY: Battery acid can burn skin and clothing. Protective eye wear and gloves should be worn when handling batteries. REPLACING THE AUXILIARY BATTERY: Ensure that the inverter is disconnected prior to disconnecting the auxiliary battery. GENERATOR: When launching a boat using your Roadtrek, it is important to know that the generator MUST NOT be submerged in water. WASTE WATER STORAGE AND DUMPING SYSTEM: Ensure that both the black and gray water gate valves are closed, (inward position) before using the waste water system. Under moderate subfreezing conditions, antifreeze is required in the exterior fresh water tank, black and gray waste water tanks. Antifreeze should be used at a 50% water and 50% antifreeze ratio. THE WARNINGS AND CAUTIONS IN THE QUICK REFERENCE ARE AN OVERVIEW AND THERE ARE MORE NOTES AND INSTRUCTIONS WITHIN THIS MANUAL. Doc No: 21906540-RSAD Rev: 00 Copyright© Hanmar Motor Corporation 2005 CUSTOMER SERVICE PROCEDURES OBTAINING MOTORHOME SERVICE The solution to all your Roadtrek concerns starts with your Roadtrek Dealer Roadtrek Dealer Roadtrek Dealer The dealership should always be given the opportunity to resolve your concerns prior to contacting Home & Park Motorhomes Dodge/Chrysler Dealer Advise the Service Department that you have a Dodge Sprinter Van that requires service. Note: Using the word "Motorhome" may cause the dealer to shy away from service. Most automotive dealers have the service capabilities to handle the 1 ton van. If situation is not resolved Contact Service Writer at Roadtrek Dealership Contact Service Writer If situation is not resolved If situation is not resolved Contact Service Manager Contact Service Manager at Roadtrek Dealership If situation is not resolved If situation is not resolved Contact Dealer Principal If situation is not resolved Contact Dealer Principal at Roadtrek Dealership If situation is not resolved Contact Chassis Customer Service Department for assistance. Customer Service will issue a file for your records. If situation is not resolved Contact Home & Park Motorhomes Contact Home & Park Motorhomes Doc No: 21906540-RSAD Rev: 00 Copyright © Hanmar Motor Corporation 2005 TABLE OF CONTENTS Introduction __________________________________________________________________________________________________ A-1 Weight Ratings ________________________________________________________________________________________________ A-2 Specifications, (Automotive/Motorhome) ________________________________________________________________________A-3 Appliance Log ________________________________________________________________________________________________A-4 Manufacturer Contact Information ______________________________________________________________________________A-5 Daily Living __________________________________________________________________________________________________ B-1 Captain's Seats ________________________________________________________________________________________________ B-1 Seat Belt Usage ________________________________________________________________________________________________ B-1 Cloverleaf Dining Table __________________________________________________________________________________________ B-2 Dinette Table __________________________________________________________________________________________________ B-3 Sleeping Facilities ______________________________________________________________________________________________ B-4 Rear Twin Beds ________________________________________________________________________________________ B-4 Rear King Bed __________________________________________________________________________________________ B-5 Front Lounge Seats ______________________________________________________________________________________ B-6 Washroom and Shower Area ______________________________________________________________________________________ B-7 Front and Rear Washroom Doors __________________________________________________________________________B-7 Washroom Exhaust Fan __________________________________________________________________________________B-7 Washroom Facilities ____________________________________________________________________________________________ B-8 Toilet ________________________________________________________________________________________________ B-8 Permanent Bathroom Shower ____________________________________________________________________________ B-8 Extra Counter Space ____________________________________________________________________________________________ B-9 TV __________________________________________________________________________________________________________ B-9 Exterior Access Doors __________________________________________________________________________________________ B-10 Driver Side Access Doors ________________________________________________________________________________ B-10 Propane Access Door __________________________________________________________________________________ B-11 Rear Storage Area ______________________________________________________________________________________ B-11 Auxiliary Battery ______________________________________________________________________________________________ B-12 Replacing the Auxiliary Battery __________________________________________________________________________________B-12 Spare Tire Storage ____________________________________________________________________________________________ B-13 Caution Note, (Mineralling) ______________________________________________________________________________________B-13 Signal Selection Switch__________________________________________________________________________________________B-14 Audio/Video Cabinet __________________________________________________________________________________________B-14 RSA Elevation Diagram __________________________________________________________________________________________B-15 RSA Floorplan ________________________________________________________________________________________________B-16 Electrical System ______________________________________________________________________________________________ E-1 Inverter ______________________________________________________________________________________________________E-1 10V Inverter/Charger Shut Down __________________________________________________________________________________E-1 Inverter/Charger Start up After Automatic Safety Shut Down ____________________________________________________________E-1 Dry Camping Battery Conservation ________________________________________________________________________________E-1 Receptacle Functionality__________________________________________________________________________________________E-1 12V DC/110V AC Inverter/Charger/Distribution Panel ________________________________________________________________ E-2 External Electrical Source Connection ______________________________________________________________________________ E-2 Generator ____________________________________________________________________________________________________ E-2 Monitor Panel __________________________________________________________________________________________________ E-3 Auxiliary Battery and Battery Separator ____________________________________________________________________________ E-4 Automotive Battery ____________________________________________________________________________________________ E-4 Interior Cab Light ______________________________________________________________________________________________ E-4 Range Hood Exhaust Fan ________________________________________________________________________________________ E-4 Water Heater __________________________________________________________________________________________________E-4 Rear Storage Light ______________________________________________________________________________________________E-4 Electrical System Legend ________________________________________________________________________________________ E-5 Electrical Distribution/Fuse Panel __________________________________________________________________________________E-6 Electrical System Schematic ______________________________________________________________________________________ E-7 Propane & Safety System ______________________________________________________________________________________ F-1 Propane Tank __________________________________________________________________________________________________ F-1 Appliances ____________________________________________________________________________________________________ F-1 Refueling Procedures ____________________________________________________________________________________________ F-2 Regulator ____________________________________________________________________________________________________ F-2 Propane Leak Detector __________________________________________________________________________________________ F-2 Carbon Monoxide Leak Detector _____________________________________________ ...