INSTRUCTION MANUAL ENGLISH MODEL: RL33SB RL33EB RL33EA Please read all the safety precautions included in this manual prior to use and retain this manual properly for future reference. Please read through this manual before connecting to power and keep it for future reference. Any change relating to this manual will result in no additional notice due to continuous improvement made on our products. DA68-01339C(5) Register your product at www.samsung.com/global/register TECHNICAL PARAMETERS MODEL DESCRIPTION Climate type Electric shock proof Total volume Effective volume Refrigerator (L) Freezer Rated voltage & frequency Total input power (W) Frost thaw power (W) Max.lighting power(W) Power consumption kWh/24h(25 C) CONTENTS RL33EB ST I 290 200 90 220V-240V~/50Hz 100 300 20 0.87 12 R-600a,60g 76 595 646 1774 RL33SB RL33EA Freezing capacity kg/24h Refrigerating agent and dosage(g) Weight (kg) Visual dimension(width*deepth*hight)(mm) Parts description-----------------------------------2 Safety notes-------------------------------------------3 Pre-running issues-----------------------------------4 Installation and Placing notes--------------------5 Control panel introduction-------------------------6 Storing Foods----------------------------------------11 Maintenance and cleaning------------------------12 Dismount method of attachment ----------------13 Trouble shooting-----------------------------------14 Technical parameters and circuit diagram----16 CIRCUIT DIAGRAM Welcome to buy the world famous brand samsung refrigerator! This manual includes three similar models of RL33SB RL33EA RL33EB ,where RL33EB is dominater by discriptions. Please read this manual and use it as instructed. The messages marked with "Warning" and "Notes" were about safety and of high importance. Please read it carefully and repeatedly. WARNING Which means it is possible to cause potential and severe damage about dangerous issues if the instructions not followed. Which means it may cause slight damage or performance failure if certain cases not avoided. NOTES 16 1 PARTS DESCRIPTION Product features Indirect cooling and frost-free: The refrigerator is the type of interval cooling and frost-free, auto defrost and even cabinet temperature. Double temperature display and double control modes: The temperature of both cooling and freeze cabinets can be read and controlled respectively. Revolving icebox: convenient for ice-making and its preservation. TROUBLE SHOOTING Refrigerator stops working - The plug is connected improperly . Structure introduction Tray egg Control panel Lamp cover Air ventilation cover Preservation cabinet shelf C C Long time running takes place - Hot in summer. - The door is opened and closed frequently. - The temperature setting is too low. - The ventilation outside of the unit is in bad situation. Egg guard Temperature sensor Can guard Sterilized & deodorized fresh-keeping box (behind fruit basket) Steel frame Bottle separation sheet The foodstuff in the refrigerator was frozen up. - The temperature setting is too low. - The foodstuff is in contact with the back cold resource. - The appliance is under the state of deepfreeze. Fruit box cover Fruit separation sheet Fruit box Revolving icebox(option) Ice storage box(option) Big bottle guard Small drawer(option) Refrigerator emits noise - The inner items are not evenly placed. - The refrigerator is installed unevenly. - The unit is located too close to wall. - The external refrigerating pipe is in collision with each other or the unit wall. - There are foreign objects behind or under the unit. - The noise is generated during compressor operation. Upper drawer Lower drawer Attachment Description Cabinet attachment Printed documents Model When the freezing function is not adequate. RL33SB 3 1 1 0 0 0 2 1 1 2 1 1 1 1 1 1 1 1 1 1 RL33EB 3 1 1 1 1 1 1 1 1 2 1 1 1 1 1 RL33EA 3 1 1 1 1 1 1 1 1 2 1 1 1 1 1 Preservation cabinet shelf Fruit box cover Fruit box Revolving icebox Ice storage box Smaller drawer Upper drawer Lower drawer Egg guard Can guard Big bottle guard Tray egg Bottle separation sheet Steel frame User manual - The door is not shut properly. - The temperature setting is too hot. - The door gasket is damaged or deformed, which impairs the sealing effect. - The refrigerator is laid near heat resource and exposed in the sunlight. - The refrigerator is stuffy inside. Door attachment The water result from frost thaws floods in the refrigerator. - The drainage outlet is blocked. If it still does not work with above causes, please ask help from the appointed repair station with The Repair Guarantee Card, or call the SAMSUNG Technical Service Center. 15 2 TROUBLE SHOOTING The front or side wall grows hot - For the sake of restraining water steam condensing on the unit frame, the frame is embedded with dew proof pipe that will heat during the unit operation. It is not a problem. - In both sides of the refrigerator was fitted with devices to drive off heat (condenser). SAFETY NOTES Cautions: If the supply cord is damaged, it must be replaced by the manufacturer or its service agent or a smililar qualified person in order to avoid hazard. The power cut-off should not be reconnected within 5 minutes to prevent the compressor being damaged. Ice crack sound. - While refrigeratory starting to run or stopping, temporary ice crack sound may be heared because the inner mechanisms occured inordinate heat expansionthe or cold shrink caused by severe temperature change,which is not a failure. Never use the combustible sprays like lacquer and paint near the machine for those will cause blasting hazard. Don't let children play with or hang on the unit as this will damage the unit or hurt children. Bicker is heard. - It's the sound arising from refrigeration agent when it flows. - It is not malfunction. Neither store inflammable, explosive items, strongacid and alkali corrosive items, such as butane, ether, benzene, sulfuric acid, gas, alcohol and so on, nor put the bottled fluid food in the freezer as the bottle might crack. When the refrigerator works in malfunction, or is damaged, operation shall be stopped immediately. Cut off the power and call the local service center. Dew appears on the inner bottom and frame. - The environment is too moist. - Not a trouble, just wipe it by cloth. Damaged power cord should be replaced by the manufacturer representatives or the personnel with same qualification. Do not splash the water to the unit back as this will impair the insulation. Dew is found in the fruit and vegetable room. - It occurs when the door is open for a long time. - The fluid food is not sealed. In case of discard the refrigeratory, please discard the door seal at first. 14 3 SAFETY NOTES NOTES DISMOUNT METHOD OF ATTACHMENT Attachment application Refrigerator shelf Lift the shelf head and pull it out. (Position the shelf as per the container height) Please refer to product's model and No. while contrasting each other; Before power supply connected, please make sure the matching between refrigeratory's voltage range and supplied voltage. The optional voltage range is from 220V to 240V; if power supply not meeting the requirement, then the auto-transformer with minimum 500 W output power should be used. In case of power supply shutdown, wait for 5 minutes or longer interval for running again lest compressor damaged. Do not place food near temperature sensor lest negative effects to correct display of temperature sensor; In hot seasons, avoid to keep door open long time or to open and close frequently, otherwise the efficiency of total set shall be weakened, and the running load shall also be increased. Keep in mind and do not reverse or make it lie down. If necessary to make it incline,the gradient between cabinet and ground should be less than 45 degree; Do not move it by holding door handle; or to pull or draw the door handle forcibly; If abundant hot items placed in at one time, keeping it open long time or opening frequently, the cabinet temperature shall be increased, and temperature display also flashes. usually it shall recover within 24 hours. The appliance must be installed so that the plug is easily accessible . WARNING Fruit Box Cover To raise up the rear portion, then take it out. Freezer tray Draw out it till the block, lift the shelf rear and pull it out. In case of heavy food stuff preserved in the drawer, hold drawer up slightly and pull it back. Keep ventilation openings, in the appliance enclosure or in the build-in structure, clear of obstruction. Do not use mechanical devices or other means to accelerate the defrosting process, other than those recommended by the manufacturer. Do not damage the refrigerant circuit. Do not use electrical appliances inside the food storage compartments of the appliance, unless they are of the type recommended by the manufacturer. Egg guard and bottle guard Lift them up to take them down. Cabinet Lamp Replacement Draw out the plug of power supply To loose the screw behind the lamp cover. And take out lamp cover by means of unclenching along its edge with flat screw-driver. PRE-RUNNING ISSUES 1. Remove all package material and remove bottom pad before running. 2. Make the interior and external clean with mild wet cloth ( little natural cleaner can be added to mild water). To screw out the bulb anti-clockwise. 3. Keep it ready and after 1 hour, plug in the power supply. Please refer to the upper indication and conduct relative operations. To screw in new bulb clockwise. To embed lamp cover again and fix the screw behind lamp cover. Lighting lamp specification: 220/240V, 20W ,E14 4 13 MAINTENANCE AND CLEANING Interior parts Dismantle all shelves, bars, trays, covers and drawers, and clean with a warm damp cloth wiper. INSTALLATION AND PLACING NOTES The refrigerator should be placed on the flat and firm floor. In case of any unevenness, regulate the adjustable foot under the body to level the refrigerator (counterclockwise means rising). Door Seal To remove and clean the door seal, use the stick wrapped by cotton cloth to clean the notch position. If cleaned with water, then to clean it dry. leave 55 mm between the back of the unit, 55 mm between the unit and the wall and 55 mm above. Water tray Screw off the screw in the compressor cover, pull up the water tray lightly and draw it out. Fix it as before after washing. The refrigerator shall be away from hot resource and direct sunlight. Ice Making Method Water line Fill water into revolving ice box until water line arrived; place the ice box carefully to the ice-making shelf. When taking out ice, turn the revolving ice box clockwise to its end and release it. Then ice can be loosed from ice making box. Store the ice in preservation box. Don't place the refrigerator in moisture as the metal parts will get rust and impair the insulation effects. In the event of natural disasters (such as rainstorm, accidents), the submerged unit shall not be put into use until nominated SAMSUNG service center repairs it and proves that it is in good condition. Ground properly for personal safety. The refrigerator shall not be grounded via phone wire or gas pipe. NOTES To draw out the plug of power supply; To make sure no water in lamp cover; To clean with neutral cleaner(recommended) WARNING Don't press the power cord. Glass separation is moveable and very heavy. Please take care of children no touching lest injured. If the placement of refrigerator is not stable enough, it may produce abnormal noise. For first time running, it takes long time to cool down from room temperature to setting temperature. usually it stops in 3 hours and keeps normal running later. 12 5 CONTROL PANEL INTRODUCTION (RL33EA*,RL33EB*) Standard indication Refrigerator Temperature Super Cool Button Vacation indication Freezer Temperature Super Freeze Button STORING FOODS Pack the foods with freshness reserving bags (films) or seal the food container with a lid to prevent drying or bad odor escaping. C C Hot food and drink should be cooled to the room temperature before putting into the refrigerator. Standard/Vacation Button Fridge Button Freezer Button Lock Button Super Cool indication Lock status indication Super Freeze indication The cooked and raw foods shall be placed separately. 1. Standard/Vacation Button 1-1. For saving energy, this product has three running modes: Standard , Vacation and user setting; 1-2. Standard : the refrigerator temperature was set to 5 , the freezer temperature was set to run at -18 . 1-3. Vacation: The refrigerate cabinet doesn't work, where the freezer keeps normal running; 1-4. User setting: The user setting modes covered all conditions except refrigerator temperature at 5 and freezer temperature at -18 .(Where in user setting mode, there was no indication of "User Setting"). 1-5. In case of first time power supplied, the refrigerator starts to run automa ...