INSTRUCTION BOOKLET COOKER HOOD ZHC 935 Thank you for buying a Zanussi product. To enable you to use your appliance effectively and safely, please read this instruction book carefully before using the appliance and retain for future reference. If you require guidance in the use of the appliance or require further information on Zanussi Products, please contact our Customer Care Department. Customer Care Department Zanussi 55 - 77 High Street Slough Berkshire SL1 1DZ Tel: 08705 727 727 To register ownership, please ensure you complete and return the guarantee card supplied with the appliance. For the User Important Safety Information Your Appliance Operating Instructions Cooker Hood Controls To Operate Recirculation Extraction Maintenance and Cleaning External Cleaning Metal Grease Filters Charcoal Filters To Remove/Replace the Charcoal Filters Changing the Light Bulb For the Installer Technical Information Electrical Connection Electrical Requirements Electrical Connection Installing the Cooker Hood Installation Requirements Unpacking Clearance Heights Fitting the Wall Brackets Fitting the Canopy Hood Venting Recirculation Fitting the Chimney Stack Something Not Working Service and Spare Parts Guarantee Conditions Guide to use the instruction book The following Symbols will be found in the text to guide you through the instruction book Safety instructions Step by step instructions 2 IMPORTANT SAFETY INFORMATION These warnings are provided in the interests of safety. Ensure that you understand them all before installing or using this appliance. Your safety is of paramount importance. If you are unsure about any of the meanings of these warnings contact the Customer Care Department. · · Installation Any installation work must be undertaken by a qualified electrician or a competent person. This hood must be installed in accordance with the installation instructions and all measurements must be adhered to. If the cooker hood is installed for use above a gas appliance then the provision for ventilation must be in accordance with the Gas Safety Codes of Practice BS.6172, BS.5440 and BS.6891 (Natural Gas) and BS.5482 (LP Gas) 1994, the Gas Safety (Installation & Use) Regulations, the Building Regulations issued by the Department of the Environment, the Building Standards (Scotland) (Consolidated) Regulations issued by the Scottish Development Department. The fan motor of this cooker hood incorporates a cut-out device which will operate if the cooker hood is installed below the height recommended under the section `Clearance Height', or if the motor becomes overheated. If the cut-out device is activated, switch off the fan motor and allow the cooker hood to cool. The cut-out device will reset itself when the fan motor has cooled significantly. It is dangerous to alter the specifications or modify this product in any way. When installed between adjoining wall cabinets the wall cabinets must not overhang the hob. If the room where the cooker hood is to be used contains a fuel burning appliance such as a central heating boiler then its flue must be of the room sealed or balanced flue type. If other types of flue or appliances are fitted ensure that there is an adequate supply of air to the room. · The ducting system for this appliance must not be connected to any existing ventilation system which is being used for any other purpose. Do not install above a cooker with a highlevel grill. · · · · Child Safety This appliance is designed to be operated by adults. Children should not be allowed to tamper with the appliance. · · · · During Use This product is for domestic use only. Never leave frying pans unattended during use as overheated fats and oils might catch fire. Never do flambé cooking under this cooker hood. Do not leave naked flames under the cooker hood. · · · · · Maintenance and Service This appliance can be a hazard if the grease filters and charcoal filters are not cleaned and replaced as recommended. Under no circumstances should you attempt to repair the appliance yourself. Repairs carried out by inexperienced persons may cause injury or more serious malfunction. Refer to your local Zanussi Service Force Centre. Always insist on genuine spare parts. · · · · · 3 YOUR APPLIANCE 265 300 740 740 min 950 max 500 898 73 OPERATING INSTRUCTIONS This cooker hood is designed to extract unpleasant odours from the kitchen, it will not extract steam. Cooker Hood Controls The cooker hood functions are controlled by five push button switches located centrally in the control fascia. L S V1 Push to switch ON the worktop lighting. Red neon indicates the fan motor is switched ON. 0-1 433 L Push to switch ON the motor at the low speed, for use with one burner or when simmering. Push to engage the medium speed, for normal cooking up to four pans. Push to engage the high speed, for use when frying or cooking foods with strong odours. MID MAX 0-1 S V1 V2 V3 V2 V3 4 To Operate Select the required fan speed and light if required. The appliance can be installed to recirculate or extract contaminated air. The cooker hood is more effective when used in the extraction mode. Recirculation The cooker hood is supplied specified for use in the recirculation mode with the charcoal filter fitted. The contaminated air is cleaned by passing through the filters and then back into the kitchen. The activated charcoal filter absorbs odours arising from cooking. In use it will slowly become saturated in grease and less effective. The filter normally requires changing at least every three months or more frequently if the hood is used for more than three hours per day. Extraction The contaminated air enters the cooker hood passing through the grease filters and out through the ducting into the atmosphere. When used in the extract mode the charcoal filter is not required and must be removed. Never do flambé cooking under this cooker hood. Take extra care when frying and never leave frying pans unattended during use, as overheated fats and oils can catch fire. Do not leave naked flames under the cooker hood. Ensure the hood is switched ON before using the hob. Ensure heating areas on your hob are covered with pots and pans when using the hob and cooker hood simultaneously. Ensure not to damage the charcoal filter when cleaning or replacing as the activated charcoal inside is saturated with grease, which will stain if it comes into contact with clothing or furnishings. 5 MAINTENANCE AND CLEANING Before carrying out any maintenance or cleaning isolate the cooker hood from the mains supply. The cooker hood must be kept clean, as a build up of grease or fat can be a fire hazard. External Cleaning The metal casing, visor and chimney should be cleaned at least once a month to keep the hood looking like new. Wipe over the hood with a soft cloth wrung out in mild soapy water and then dry thoroughly. Always wear protective gloves when cleaning the hood. Never use scouring pads or abrasive cleaners as they may scratch of damage the surfaces. Never use excessive amounts of water when cleaning particularly around the control panel. Metal Grease Filter The metal grease filter should be cleaned at least every month. The filter may be washed by hand using mild soapy water, or can be machine washed in a dishwasher. Allow to dry completely before replacing. To Remove the Grease Filter Remove the metal grease filter by pushing inwardly on the two steel handles; replace, making sure the handles have sprung back into position and are completely visible. 6 MAINTENANCE AND CLEANING Charcoal Filter The charcoal filter cannot be cleaned or regenerated, it should be replaced approximately every three months or more frequently if the hood is used for more than three hours per day. To Remove the Charcoal Filter Remove the metal grease filter. Release the fixing hooks and remove the charcoal filter from the recess. Insert the replacement filter into the recess and replace the hooks. Replace the metal grease filter. This appliance can be a possible fire hazard if the grease and charcoal filters are not cleaned and replaced as recommended. Worktop Lighting The lamps should be replaced with a 230V 20W halogen spot lamp. To Replace the Lamps Unscrew the two screws to release the metal surround. Remove the lamp from the holder by pulling the lamp downwards. Replace the spot lamp with an identical replacement. When fitting the new lamp ensure the two pins are properly inserted into the slots in the lamp holder. Charcoal filters, grease filters and lamps can be obtained from your local Service Force Centre. 7 SOMETHING NOT WORKING If, having followed these instructions carefully, your cooker hood fails to work properly please carry out the following checks. Symptom The cooker hood will not start Solution · · · · · · · Check the hood is connected to the electricity supply. Make sure the switch is in the `ON' position. The fan speed is set high enough for the task. The grease filter is clean. The kitchen is adequately vented to allow the entry of fresh air. If set up for recirculation, check that the charcoal filter is still effective. If set up for extraction, check that the ducting outlets are not blocked. The safety cut-out device has been tripped. Turn off the hob and then wait for the device to reset. The cooker hood has switched off during operation · · If after all these checks, the fault persists, contact your local Service Force Centre, quoting the model and serial number. Please note that it will be necessary to provide proof of purchase for any in-guarantee service calls. In-guarantee customers should ensure that the above checks have been made as the engineer will make a charge if the fault is not a mechanical or electrical breakdown. SERVICE AND SPARE PARTS If you require an engineer or spare parts contact your local Service Force Centre by telephoning: For general assistance with your appliance or for further information on Zanussi products please contact our Customer Care Department. Customer Care Department Zanussi 55 - 77 High Street Slough Berkshire SL1 1DZ Telephone: 08705 727 727* * calls to this number may be recorded for training purposes. 08705 929929 Your telephone call will be routed to your local Service Force Centre. For the address of your local Service Force Centre and further information about Service Force, please visit the website at www.serviceforce.co.uk 8 GUARANTEE CONDITIONS We, Zanussi, undertake that if within twenty four months of the date of the purchase this Zanussi built-in product or any part thereof is proved to be defective by reason only of faulty workmanship or materials, the company will, at our option repair or replace the same FREE OF ANY CHARGE for labour, materials or carriage on condition that: · · · · · The appliance has been correctly installed and used only on the electrical supply stated on the rating plate. The appliance has been used for normal domestic purposes only, and in accordance with the manufacturer's operating and maintenance instructions. The appliance has not been serviced, maintained, repaired, taken apart or tampered with by any person not authorised by us. All service work under this guarantee must be undertaken by a Zanussi Service Force Centre. Any appliance or defective part replaced shall become the property of this company. Home visits are made between 8.30am and 5.30pm Monday to Friday. Visits may be available outside these hours in which case a premium will be charged. EXCLUSIONS This Guarantee does not cover: · · · · Damage or calls resulting from transportation, improper use or neglect, the replacement of any lamps or removable parts of glass or plastic. Costs incurred for calls to put right appliances improperly installed or calls to appliances outside the United Kingdom. Appliances found to be in use within a commercial environment, plus those which are the subject of rental agreements. Products of Zanussi manufacture which are not marked by Zanussi. This guarantee is in addition to your statutory and legal rights. ZANUSSI EUROPEAN GUARANTEE If you should move to another country within Europe then your guarantee moves with you to your new home subject to the following qualifications: · · · · · The guarantee starts from the date you first purchased the product. The guarantee is for the same period and to the same extent for labour and parts as exists in the new country of use for this brand or range of products. This guarantee relates to you and cannot be transferred to another user. Your new home is within the European Community (EC) or European Free Trade Area. The product is installed and used in accordance with our instructions and is only used domestically, i.e. a normal household. Before you move please contact your nearest Customer Care Centre, listed below, to give them detailsof your new home. They will then ensure ...