BUILT-IN OVEN ZOB 660 INSTRUCTION BOOKLET Please read this instruction booklet before using the appliance GB Important Safety Information You MUST read these warnings carefully before installing or using the oven. If you need assistance, contact our Customer Care Department on 08705 727727 Installation · · · · This oven must be installed by qualified personnel to the relevant British Standards. This oven is heavy. Take care when moving it. Remove all packaging, both inside and outside the oven, before using the oven. Do not attempt to modify the oven in any way. · When using other electrical appliances, ensure the cable does not come into contact with the hot surfaces of the oven. Maintenance and Cleaning · · Only clean this oven in accordance with the instructions. The oven should be kept clean at all times. A build-up of fats or other foodstuffs could result in a fire, especially in the grill pan. Never use steam or high pressure steam cleaners to clean the appliance. Always allow the oven to cool down and switch off the electrical supply before carrying out any cleaning or maintenance work. Child Safety · · This oven is designed to be operated by adults. Do not allow children to play near or with the oven. The oven gets hot when it is in use. Children should be kept away until it has cooled. · · During Use · · This oven is intended for domestic cooking only. It is not designed for commercial or industrial purposes. Appliances become very hot with use, and retain their heat for long periods after use. Care should be taken to avoid touching heating elements inside the oven. Always stand back from the oven when opening the oven door during cooking or at the end of it to allow any build up of steam or heat to release. Never line any part of the oven with aluminium foil. Do not allow heatproof cooking material, e.g. roasting bags, to come into contact with oven elements. Never place plastic or any other material which may melt in or on the oven. Do not place sealed cans or aerosols inside the oven. They may explode if they are heated. Do not hang towels, dishcloths or clothes from the oven or its handle. Do not use this oven if it is in contact with water and never operate it with wet hands. Take great care when heating fats and oils as they will ignite if they become too hot. Always use oven gloves to remove and replace food in the oven. Ensure that all control knobs are in the OFF position when not in use. Do not leave cookware containing foodstuffs, e.g. fat or oil in or on the oven in case it is inadvertently switched ON. Service · This oven should only be repaired or serviced by an authorised Service Engineer and only genuine approved spare parts should be used. · Environmental Information · · After installation, please dispose of the packaging with due regard to safety and the environment. When disposing of an old appliance, make it unusable, by cutting off the cable. Remove any door catches, to prevent small children being trapped inside. · · · · · · · · · · Keep this instruction book for future reference and ensure it is passed on to any new owner. 2 Contents For the User Important Safety Information Description of the Oven Controls Before the First Use Electronic Programmer Using the Oven Hints and Tips Using the Conventional Oven The Fan Oven Cooking Chart-Conventional and Fan Oven Grilling Defrosting Cleaning the Oven Care of Catalytic Liners Cleaning the Hinged Grill Replacing the Oven Light Something not Working Service and Spare Parts Customer Care Guarantee Conditions 2 4 5 6 7 9 9 10 11 12 13 14 15 16 17 17 18 18 19 19 For the Installer Installation Electrical Connection Building In 20 20 21 Guide to use the instructions The following symbols will be found in the text to guide you throughout the Instructions: Safety Instructions Step by step instructions for an operation Hints and Tips Environmental information This appliance complies with the following E.E.C. Directives: *73/23 - 90/683 (Low VoltageDirective); *93/68 (General Directives); *89/336 (Electromagnetical Compatibility Directive) and subsequent modifications. 3 Description of the Oven 65 4 3 2 1 8 7 9 10 1. Control panel 2. Oven Control Function Knob 3. Electronic Programmer 4. Thermostat Control Knob 5. Mains on Light 6. Thermostat Control Light 7. Oven Light 8. Grill 9. Oven Fan 10.Rating Plate Oven accessories Removable handle Grill Pan Grid Anti-tip shelf (x 2) Grill / Roasting pan 4 Controls Oven Function Control Knob 0 The oven is off Oven light - The oven light will be on without any cooking function Conventional cooking - The heat comes from both the top and bottom element, ensuring even heating inside the oven Inner grill element only - Can be used for grilling small quantities Full Grill - The full grill element will be on Fan cooking - This allows you to roast or roast and bake simoultaneously using any shelf, without flavour transference Defrost Setting - This setting is intended to assist in thawing of frozen food. Mains on Light The mains on light will come on when the oven function control knob is set. The cooling fan The cooling fan operates during cooking. Air is expelled through vents between the oven door and the control panel, as shown in the diagram. The cooling fan may run on after the oven is switched off to keep the controls cool. This is quite normal. 5 Thermostat Control Knob (°C) Turn the thermostat control knob clockwise to select temperatures between 50 °C and 230 °C (MAX). 5 0 MAX Thermostat Control Light The thermostat control light will come on when the thermostat control knob is turned. The light will remain on until the correct temperature is reached. It will then cycle on and off to show the temperature is being maintained. 100 The Safety Thermostat This oven is provided with a safety thermostat. In case of malfunctioning of the main thermostat, and consequential over-heating, the safety device will stop the power supply to the appliance. If this happens, call your local Service Force Centre. Under no circumstances should you attempt to repair the appliance yourself. Before the First Use Remove all packaging, both inside and outside the oven, before using the oven. Before first use, the oven should be heated without food. During this time, an unpleasant odour may be emitted. This is quite normal. The oven will work only if the time of day has been set. 1. Set the time of day with the electronic programmer (see chapter "Electronic Programmer"). 2. Switch the oven function control knob to fan cooking . 3. Set the thermostat control knob to MAX. 4. Open a window for ventilation. 5. Allow the oven to run empty for approximately 45 minutes. This procedure should be repeated with the full grill function for approximately 5-10 minutes. 6 0 20 150 Electronic Programmer 4 5 6 7 8 1. Push button for selecting a function 2. Decreasing control button " " 3. Increasing control button " " 4. Display 5. "Cooking Duration" pilot lamp 6. "End of cooking" pilot lamp 2 1 3 7. "Minute minder" pilot lamp 8. "Time of day" pilot lamp The oven will only work if the time of day has been set. However, the oven can also be operated without any programme. Setting the time of day When the power supply is switched on, or after a power failure, the "Time of day" pilot lamp will flash on the display. To set the correct time of day: 1. Press button " " or " ". 2. After the setting is carried out, wait for 5 seconds: the "Time of day" pilot lamp will go out and the display will show the set time. The appliance is ready for use. To reset the correct time of day: 1. Press button repeatedly to select the "Time of day" function. The relevant pilot lamp will start flashing. Then proceed as described above. The time of day can only be reset if no automatic function (cook duration or end of cooking ) has been set. "Cooking Duration" function This function allows the oven to automatically switch off at the end of a programmed cooking duration time. Place food in the oven, select a cooking function and adjust the cooking temperature. Press button repeatedly to select the "Cooking Duration" function. The relevant pilot lamp will start flashing. Then, proceed as follows: To set the duration time: 1. Press button " " or " ". 2. After the setting is carried out, wait for 5 seconds: the "Cooking Duration" pilot lamp will come on and the display will revert to the time of day. 3. When cooking time is over, the oven will be switched off automatically and an acoustic alarm will be heard, while the pilot lamp will start flashing. Turn the oven function and the thermostat control knob to zero. To switch off the acoustic alarm, press any button. NOTE: turning the acoustic alarm off will reset the oven to manual, and if the oven function and the thermostat knobs are not set to zero the oven will start to heat again. To cancel the duration time: 1. Press button repeatedly to select the "Cooking Duration" function. The relevant pilot lamp will flash and the display will show the remaining cooking time. 2. Press button " " until the display shows "0:00". After 5 seconds the pilot lamp will go out and the display will revert to the time of day. 7 "End of cooking" function With this function, you can set the oven to switch off automatically when a programmed end of cooking time is over. Place food in the oven, select a cooking function and adjust the cooking temperature. Press button repeatedly to select the "End of cooking" function. The relevant pilot lamp will start flashing. Then, proceed as follows: To set the End of cooking time: 1. Press button " " or " ". 2. After the setting is carried out, wait for 5 seconds: the "End of cooking" pilot lamp will come on and the display will revert to the time of day. 3. When cooking time is over, the oven will be switched off automatically and an acoustic alarm will be heard, and the pilot lamp will start flashing. Turn the oven function and the thermostat control knob to zero. To switch off the acoustic alarm, press any button. NOTE: turning the acoustic alarm off will reset the oven to manual, and if the oven function and the thermostat knobs are not set to zero the oven will start to heat again. To cancel the End of cooking time: 1. Press button repeatedly to select the "End of cooking" function. The relevant pilot lamp will flash and the display will show the programmed End of cooking time. 2. Press button " " until the display shows the current time of day. The programmer will beep and the pilot lamp will go out. "Cooking duration" time" combined and "End of cooking The functions "Cooking duration" and "End of cooking time" can be used simultaneously to set the oven to switch on and off automatically at a later time. 1. With the "Cooking duration" function (carry out the cooking duration setting as described in the relevant chapter) set the duration time. Then, press button : the display will show the programmed setting. (carry out the End of cooking 2. With the "End of cooking time" function setting as described in the relevant chapter) set the end of cooking time. The relevant pilot lamps will come on and the display will show the time of day. The oven will switch on and off according to the set programmes. "Minute minder" function The minute minder alarm will sound at the end of a timed period, but THE OVEN WILL REMAIN ON, if it is in use. To set the minute minder: 1. Press button repeatedly to select the "Minute minder" function. The relevant pilot lamp will start flashing. 2. Then, press button " " or " " (maximum: 2 hours, 30 minutes). 3. After the setting is carried out, wait for 5 seconds: the "Minute minder" pilot lamp will come on. 4. At the end of the timed period, the pilot lamp will start flashing and an acoustic alarm will be heard. To switch off the acoustic alarm, press any button. To cancel the minute minder: 1. Press button repeatedly to select the "Minute minder" function. The relevant pilot lamp will flash and the display will show the remaining time. 2. Press button " " until the display shows "0:00". After 5 seconds the pilot lamp will go out and the display will revert to the time of day. How to switch off the display 1. Press two or three programmer push buttons simoultaneously and keep them pressed for about 5 seconds. The display will switch off. 2. To switch on the display, press any button. The display can be switched off only if no other functions have been set. 8 Using the Oven Always cook with the oven door closed. Stand clear when opening the drop down oven door. Do not allow it to fall open - support the door using the door handle, until it is fully open. The oven has four shelf levels, and is supplied with two shelves. The shelf positions are counted from the bottom of the oven as shown in the diagram. It is important that these shelves are correctly positioned as shown in the diagram. Do not place cookware directly on the oven ba ...